Abstract:Paucilactobacillus wasatchensis can use gluconate (GLCN) as well as galactose as an energy source and because sodium GLCN can be added during salting of Cheddar cheese to reduce calcium lactate crystal formation, our primary objective was to determine if the presence of GLCN in cheese is another risk factor for unwanted gas production leading to slits in cheese. A secondary objective was to calculate the amount of CO2 produced during storage and to relate this to the amount of gas-forming substrate that was utilized. Ribose was added to promote growth of Pa. wasatchensis WDC04 (P.waWDC04) to high numbers during storage. Cheddar cheese was made with lactococcal starter culture with addition of P.waWDC04 on 3 separate occasions. After milling, the curd was divided into six 10-kg portions. To the curd was added (A) salt, or salt plus (B) 0.5% galactose + 0.5% ribose (similar to previous studies), (C) 1% sodium GLCN, (D) 1% sodium GLCN + 0.5% ribose, (E) 2% sodium GLCN, (F) 2% sodium GLCN + 0.5% ribose. A vat of cheese without added P.waWDC04 was made using the same milk and a block of cheese used as an additional control. Cheeses were cut into 900-g pieces, vacuum packaged and stored at 12°C for 16 wk. Each month the bags were examined for gas production and cheese sampled and tested for lactose, galactose and GLCN content, and microbial numbers. In the control cheese, P.waWDC04 remained undetected (i.e., <104 cfu/g), whereas in cheeses A, C, and E it increased to 107 cfu/g, and when ribose was included with salting (cheeses B, D, and F) increased to 108 cfu/g. The amount of gas (measured as headspace height or calculated as mmoles of CO2) during 16 wk storage was increased by adding P.waWDC04 into the milk, and by adding galactose or GLCN to the curd. Galactose levels in cheese B were depleted by 12 wk while no other cheeses had residual galactose. Except for cheese D, the other cheeses with GLCN added (C, E and F) showed little decline in GLCN levels until wk 12, even though gas was being produced starting at wk 4. Based on calculations of CO2 in headspace plus CO2 dissolved in cheese, galactose and GLCN added to cheese curd only accounted for about half of total gas production. It is proposed that CO2 was also produced by decarboxylation of amino acids. Although P.waWDC04 does not have all the genes for complete conversion and decarboxylation of the amino acids in cheese, this can be achieved in conjunction with starter culture lactococcal. Adding GLCN to curd can now be considered another confirmed risk factor for unwanted gas production during storage of Cheddar cheese that can lead to slits and cracks in cheese. Putative risk factors now include having a community of bacteria in cheese leading to decarboxylation of amino acids and release of CO2 as well autolysis of the starter culture that would provide a supply of ribose that can promote growth of Pa. wasatchensis.

Decarboxylase activity of the non-starter lactic acid bacterium Loigolactobacillus rennini gives crack defects in Gouda cheese through the production of γ-aminobutyric acid

Gas production by Paucilactobacillus wasatchensis WDCO4 is increased in Cheddar cheese containing sodium gluconate

Gluconate metabolism and gas production by Paucilactobacillus wasatchensis WDC04

Lactobacillus delbrueckii subsp. lactis as a starter culture significantly affects the dynamics of volatile compound profiles of hard cooked cheeses

Influence of Milk Pasteurization on the Key Aroma Compounds in a 30 Weeks Ripened Pilot-Scale Gouda Cheese Elucidated by the Sensomics Approach

Production of Naturally γ-Aminobutyric Acid-Enriched Cheese Using the Dairy Strains Streptococcus thermophilus 84C and Lactobacillus brevis DSM 32386

Influence of microflora on texture and contents of amino acids, organic acids, and volatiles in semi-hard cheese made with DL-starter and propionibacteria

Indigenous Lactic Acid Bacteria Isolated from Raw Graviera Cheese and Evaluation of their Most Important Technological Properties

Cheese yeasts

Abundance and potential contribution of Gram-negative cheese rind bacteria from Austrian artisanal hard cheeses

Symposium review: Interaction of starter cultures and nonstarter lactic acid bacteria in the cheese environment

Nucleic acid-based approaches to investigate microbial-related cheese quality defects

Interaction between a Lactococcus lactis autochthonous starter and a raw goat milk microbial community during long-term backslopping

Late blowing of Cheddar cheese induced by accelerated ripening and ribose and galactose supplementation in presence of a novel obligatory heterofermentative nonstarter Lactobacillus wasatchensis.

The influence of technological methods for the production of ripening cheeses on the development and metabolism of the acid-forming component of the bacterial starter culture of Lactococcus lactis subsp. cremoris.

Probiotic Potential and Application of Indigenous Non-Starter Lactic Acid Bacteria in Ripened Short-Aged Cheese

Potential of Cheese-Associated Lactic Acid Bacteria to Metabolize Citrate and Produce Organic Acids and Acetoin

Lactic acid bacteria in cow raw milk for cheese production: Which and how many?

Characterization of a Lactobacillus strain producing white crystals on cheddar cheese

Lactic Acid Bacteria in Raw-Milk Cheeses: From Starter Cultures to Probiotic Functions