Abstract:BackgroundPig manure utilization and valorization is an important topic with tightening regulations focused on ecological and safety issues. By itself pig manure is a poor substrate for biogas production because of its excessive nitrogen content relative to available organic carbon. Such substrate is alkaline, and methanogenesis can be suppressed, and so additional substrates with high organic carbon must be added. The most promising is straw, which is available from adjacent biogas plant cultures. However, the abundant lignocellulosic biomass of wheat straw undergoes slow decomposition, and only a fraction of the chemical energy can be converted into biogas; thus economical methods for pretreatment increasing bioavailability are sought.ResultsA method was investigated to increase the methane yield in a full-scale plant for co-fermenting pig manure with corn silage, which was the default substrate in the original source reactors. Increased lignocellulosic bioavailability of wheat straw was achieved by combining liquid hot water (LHW) and steam explosion (SE). According to FT-IR analysis, the treatment resulted in hemicellulose hydrolysis, partial cellulose depolymerization, and lignin bond destruction. Low-mass polysaccharides (0.6 × 103 g mol−1) had significantly higher concentration in the leachate of LHW-SE wheat straw than raw wheat straw. The methanogenic potential was evaluated using inoculum from two different biogas plants to study the influence of microorganism consortia. The yield was 24–34% higher after the pretreatment process. In a full-scale biogas plant, the optimal conditions were ~ 165 °C, ~ 2.33 MPa, and 10 min in LHW and ~ 65 °C and ~ 0.1 MPa for SE. The processes did not generate detectable inhibitors according to GC–MS analysis, such as furfural and 5-hydroxymethylfurfural.ConclusionsThe LHW-SE combined pretreatment process increases the bioavailability of carbohydrates from wheat straw. The LHW-SE treated wheat straw gave similar biogas yields to corn silage, thus enables at least partial replacement of corn silage and is good for diversification of substrates. Surprisingly, microorganisms consortia from other biogas plant fed with other substrates may have higher efficiency in utilization of tested substrate. Thus, methanogenic consortia may be considered in the process of optimization at industrial scale. The efficiency was calculated, and the LHW-SE may be profitable at full industrial scale and further optimization is proposed.

Enhancement of biogas production from rape straw using different co-pretreatment techniques and anaerobic co-digestion with cattle manure

Fungal Pretreatment of Rice Straw with Pleurotus Ostreatus and Trichoderma Reesei to Enhance Methane Production under Solid-State Anaerobic Digestion

Combinations of Fungal and Milling Pretreatments for Enhancing Rice Straw Biogas Production During Solid-State Anaerobic Digestion.

Effect of hydrothermal and Ca(OH)2 pretreatments on anaerobic digestion of sugarcane bagasse for biogas production.

Technical Assessment of Bioenergy Recovery from Cotton Stalks Through Anaerobic Digestion Process and the Effects of Inexpensive Pre-Treatments

Enhancement of methane production from Cotton Stalk using different pretreatment techniques

Thermal-alkali and Enzymes for Efficient Biomethane Production from Co-digestion of Corn Straw and Cattle Manure

Optimization of mixed microbes pretreatment on corn straw for enhancing methane production

Enhancing biogas production from hemp biomass residue through hydrothermal pretreatment and co-digestion with cow manure: Insights into methane yield, microbial communities, and metabolic pathways

Effect of Biochar on Methane Production and Structural Characteristics in the Anaerobic Digestion (AD) of Rape Straw

Enhancement on methane production and anaerobic digestion stability via co-digestion of microwave-Ca(OH)<sub>2</sub> pretreated sugarcane rind slurry and kitchen waste

Effect of alkaline pretreatment on the characteristics of barley straw and modeling of methane production via codigestion of pretreated straw with sewage sludge

[Performance of Treating Straw and Animal Manure Mixture by an Integrated Process of Thermo-alkali-bi-enzyme Hydrolysis-anaerobic Digestion and Conditions of High Methane Yield].

Anaerobic co-digestion of linen, sugar beet pulp, and wheat straw with cow manure: effects of mixing ratio and transient change of co-substrate

Enhancement on methane production and anaerobic digestion stability via co-digestion of microwave-Ca(OH)2 pretreated sugarcane rind slurry and kitchen waste

A Review of Crop Straw Pretreatment Methods for Biogas Production by Anaerobic Digestion in China

Enhancing biogas plant production using pig manure and corn silage by adding wheat straw processed with liquid hot water and steam explosion

Rumen fluid pretreatment promotes anaerobic methane production: revealing microbial dynamics driving increased acid yield from different concentrations of corn straw

Mixed ensiling plus nitrate destroy fiber structure of rape straw, increase degradation, and reduce methanogenesis through in vitro ruminal fermentation

Synergistic And Pretreatment Effect On Anaerobic Co-Digestion From Rice Straw And Municipal Sewage Sludge

Enhanced straw fermentation process based on microbial electrolysis cell coupled anaerobic digestion