Experimental study on the treatment of desulfurization wastewater from coal-fired power plant by spray evaporation
Zongkang Sun,Ning Zhao,Yongxin Feng,Fengjun Liu,Chenjian Cai,Guangmin Che,Yaping Zhang,Hao Wu,Linjun Yang
DOI: https://doi.org/10.1007/s11356-022-21859-7
IF: 5.8
2022-07-26
Environmental Science and Pollution Research
Abstract:In this study, a pilot-scale evaporation tower system was built to treat the desulfurization wastewater by spray evaporation. The distribution characteristics of Cl − in the wastewater evaporation process were investigated. Besides, the morphology and physicochemical property of solid evaporation products from desulfurization wastewater were analyzed. In addition, the emission characteristics of fine particulates were evaluated. The results indicated that the increase of salt content in desulfurization wastewater increased the mass concentrations of Cl − in three phases, but the proportions of it remained almost unchanged, which were about 10%, 55%, and 35% in the gas phase, outlet solid phase, and bottom solid phase respectively. The increase of flue gas temperature can improve the content of Cl − in the gas phase, while the increase of wastewater pH inhibited the formation of gaseous HCl. The solid evaporation products from desulfurization wastewater had a prismatic crystal structure, which mainly included the sulfate and chloride salts, and the main elements including O, Na, Mg, S, Cl, K, and Ca. Besides, the peak values of particle size distribution in the bottom solid phase and outlet solid phase were 7.67 and 0.32 μm, respectively. For the particulate matters in flue gas, the spray evaporation of desulfurization wastewater can reduce the particle concentration, promote particle agglomeration, reduce the number concentration of fine particles, and improve the removal effect of PM 10 . When the inlet particle concentration was 7.62 g/m 3 , it can reduce the particle concentration at the tower outlet to 4.59 g/m 3 and reduce the number and mass concentrations of PM 10 after ESP by about 43.8% and 36.8%.
environmental sciences