Abstract:In order to improve methane production from maize straw, crude enzymes from Trichoderma harzianum and Aspergillus sp. by solid-state fermentation were used to pretreat the maize straw before anaerobic fermentation. The experiment was divided into two parts: pretreatment and anaerobic digestion. Enzymatic treatments were done using enzymes (enzyme from Trichoderma harzianum,named as enzyme T;and enzyme from Aspergillus sp,named as enzyme A)inoculated into dry yellow maize straw at 50 ℃ for 6 days. The enzymes had the ability to hydrolyze cellulose and hemicellulose, and the CMCase and xylanase activity in enzyme T were (12.38 ± 0.69) and (230.53 ± 23.03) U/mL, from enzyme A were (3.32 ± 0.68) and (891.77±27.36) U/mL, respectively. Control samples (CK) were prepared using the same conditions as in enzymatic treatment, but with no enzyme added. Maize straw was pretreated for 6 days as the fermentation substrates and the sludge was inoculum. The working volume of each suction-flask reactor was 1 L, and 300 mL inoculum was loaded into each reactor. Batch tests were conducted in a walk-in incubation room for 20 days at (35±2) ℃. Triplicate reactors were run for each condition. Inoculum without any added feedstock was used as a blank. The biogas production and methane composition were measured every day and the pH value, volatile fatty acids (VFA), soluble chemical oxygen demand (sCOD) and alkalinity were measured during the fermentation. The relationship between VFA and sCOD or VFA and alkalinity during anaerobic fermentation was analyzed. High-throughput sequencing was used to determine the microbial community structure in 24 hours fermentation samples, in order to detect the effect of enzymatic pretreatment and its impact on the bacteria and archaea community in anaerobic fermentation system. The results showed that VFA concentration increased significantly after treated by enzyme T and enzyme A, and mainly reflected in the accumulation of acetic acid content at 0 d. After 2 days fermentation, propionic acid was the main component of VFA. At the 1stday, the ratio of alkalinity/VFA and sCOD/VFA of enzyme T group and enzyme A group were significantly increased, which were 18.69 and 8.69 in enzyme T group, and 10.89 and 7.18 in enzyme A group, respectively. These changes were mainly due to the decrease of VFA. However, CK group in both alkalinity/VFA and sCOD/VFA showed a gradual decline trend. The cumulative methane yield by enzyme T group and enzyme A group were increased by 7.79% and 10.06%, respectively, compared with the control. After 24 hours fermentation, the abundance of 9 genus of bacteria in enzyme T group were increased than CK group, and Clostridium, vadinBC27 and Ruminofilibacter were related to the degradation of cellulose.The bacteria in enzyme A group was similar with CK group,and only 5 genus were significant difference. The main archaea were Methanosaeta, Bathyarchaeota, Methanosarcina, Deep sea Euryarchaeotic Group-DSEG and Methanobacterium.The pretreatment could affect the microbial structure in the fermentation system. Effective pretreatment plays an important role in anaerobic digestion of lignocellulose. This study provides important theoretical and technical support for the use of enzymes in methane production of agricultural wastes.

Preparation of bacterial fertilizer from biogas residue after anaerobic co-digestion of kitchen waste and residual sludge

Optimization for Fermentation of Cattle Manure to Produce Bio-Fertilizer by Inoculating Complex Microbial Agents

The Potential of Fecl3-Modified Biogas Residue Biochar for the Enhancement of Anaerobic Digestion of Food Waste by Promoting Direct Interspecies Electron Transfer: Discernment of Pivotal Microbe and Metabolism

Experiment on Anaerobic Fermentation with Lawn Waste for Eco-campus

Enhancement of biogas production in anaerobic co-digestion of food waste and waste activated sludge by biological co-pretreatment

Converting Digested Residue Eluted from Dry Anaerobic Digestion of Distilled Grain Waste into Value-Added Fertilizer by Aerobic Composting

Improvement of anaerobic fermentation efficiency of wastewater sludge in a nucleotide plant by pretreatment and adding cow dung

Enhancement of Aerobic Composting Performance of Biogas Residue Through Inoculation of Bacillus Subtilis Z2

Study of the Performance of Biogas Production by Mixed Fermentation of Cow Dung, Deer Manure, and Mushroom Fungus

Composting of the Solid Phase of Digestate from Biogas Production: Optimization of the Moisture, C/N Ratio, and pH Conditions

Enhancing the Conversion of Organic Waste into Biofertilizer with Thermophilic Bacteria

Optimization of Biogas Production of Mixed Raw Materials

Enhancing biomethanation performance through co-digestion of diverse organic wastes: a comprehensive study on substrate optimization, inoculum selection, and microbial community analysis

Role of multistage inoculation on the co-composting of food waste and biogas residue

Wet and Dry Coupling Anaerobic Fermentation Process and Fermentation Characteristic Test

Biogas Residues Improved Microbial Diversity and Disease Suppression Function under Extent Indigenous Soil Microbial Biomass.

Optimization of Solid-state Fermentation Conditions for Antagonistic Bacillus Subtilis SQR9 Producing Bio-organic Fertilizer

Silage Fermentation and Bacterial Community of Bur Clover, Annual Ryegrass and Their Mixtures Prepared with Microbial Inoculant and Chemical Additive

Promote Lactic Acid Production from Food Waste Fermentation Using Biogas Slurry Recirculation.

Effect of bioaugmentation on lignocellulose degradation and antibiotic resistance genes removal during biogas residues composting

Pretreatment by crude enzymatic liquid from Trichoderma harzianum and Aspergillus sp improving methane production performance during anaerobic digestion of straw