Abstract:The co-firing of various ultra-low volatile coal-based solid wastes (CSWs) under oxy-fuel condition is a promising approach to elevate the energy conversion efficiency in coal chemistry industry. However, the kinetics and thermal transformation mechanisms during oxy-fuel co-combustion of various CSWs blends are still vague, which need to be further elucidated. Here, the physical–chemical features of CSWs were firstly revealed. Moreover, the oxy-fuel co-combustion characteristics and kinetics of various CSWs were investigated. The results illustrate that four chemical forms of fuel nitrogen could be obtained in pyrolyzed semi-coke (PS), while only two occurrence forms of fuel nitrogen were observed in two residual carbons, including fluidized bed gasification residual carbon (FRC) and coal-water-slurry gasification residual carbon (CRC). The reactivities of various samples could be promoted by the increasing temperature during gasification process. The combustion of volatile matter and fixed carbon could be promoted by an increase in oxygen content in oxy-fuel atmosphere. The combustion characteristic index (S) of 50% PS/50% CRC is raised by 59.3% and that of 50% PS/50% FRC is increased by only 19.0% with the oxygen concentration elevated from 30 to 40%. The effects of rising residual carbon proportion on PS/CRC blend are more obvious than those on PS/FRC blend. The additive of PS in blend could promote the combustion behaviors of residual carbon, especially on CRC. The mass loss rate of 50% PS/50% CRC blend changes significantly with the heating rate, which is greater than that of 50% PS/50% FRC blend. The average apparent activation energy (Eam) of 50% PS/50% CRC blend is lower than that of linear calculation result. The Eam of CRC could be reduced by blending PS, and the poor combustion behaviors of CRC are improved by addition of PS.Graphic abstract

The study of co-combustion characteristics of coal and duckweed by single particle and TGA methods

Investigation on the co-combustion characteristics of multiple biomass and coal under O2/CO2 condition and the interaction between different biomass.

Co-combustion of Coal and Carbonaceous Wastes: Thermogravimetric Analysis

Thermodynamics and synergistic effects on the co-combustion of coal and biomass blends

Co-combustion Characteristics and CO2 Emissions of Low-Calorific Multi-Fuels by TG-FTIR Analysis

The Thermal Behavior and Kinetics of Co-Combustion Between Sewage Sludge and Wheat Straw

Co-combustion of pulverized coal and walnut shells in air and oxy-fuel atmospheres: Thermal behavior, synergistic effect and kinetics

A DNS Study on Temporally Evolving Jet Flames of Pulverized Coal/biomass Co-Firing with Different Blending Ratios

Experimental study on co-firing characteristics of coal/biomass blends in O2/CO2 atmosphere

Experimental and Numerical Investigation of the Combustion Characteristics and NO Emission Behaviour During the Co-Combustion of Biomass and Coal

Comprehensive study on co-combustion behavior of pelletized coal-biomass mixtures in a concentrating photothermal reactor

Co-combustion of wheat straw and camphor wood with coal slime: Thermal behaviour, kinetics, and gaseous pollutant emission characteristics

Co-Combustion Characteristics of Typical Biomass and Coal Blends by Thermogravimetric Analysis

Comprehensive Experimental Investigations on Co-combustion Dynamics and Multi-pollutant Formation Characteristics of Coal Gangue and Biomass in Oxy-fuel Atmosphere

Experimental investigation on co-combustion characteristics of semi-coke and coal: Insight into synergy and blending method

On the Co-Combustion Characteristics and Kinetics of Sludge, Wood Chips, and Bituminous Coal

Feasibility of co-disposal of lignite and eucalyptus wood in coal-fired power plants: thermogravimetric characterization, typical gaseous pollutant emission characteristics, and economic analysis

Oxy-fuel co-combustion characteristics and kinetics of various ultra-low volatile coal-based solid waste blends

Thermogravimetric analysis of the co-combustion of coal and paper mill sludge

Comparative insights into flue gas-to-ash characteristics on co-combustion of walnut shell and bio-oil distillation sludge under atmospheric and oxy-fuel condition

Thermogravimetric analysis on the co-combustion of biomass pellets with lignite and bituminous coal