Abstract:In situ temperature ellipsometry is used to probe the expansion of a collection of conjugated polymers and small molecules. Correlation of the melt expansion with the literature derived g‐parameters, in other words the disorder, in the polymer systems is observed contrary to prior understanding. Low temperature relaxations are observed that suggest reorientation of the polymer systems and reduction of as‐cast anisotropy. The molecular self‐organization and reorganization and thus volumetric and density changes during structural relaxation and melting of modern organic semi‐conducting materials remains largely unknown, particularly in the device relevant thin film geometry where the initial state may be structurally quenched away from equilibrium. Here, the apparent mass‐thickness of a range of semi‐conducting polymeric or molecular model materials systems is measured through in situ ellipsometry. Surprisingly, the volume changes upon melting correlate inversely, with a few exceptions, to the quality of crystallinity found via x‐ray methods (i.e., directly correlate with the paracrystalline g‐parameter) rather than the melting enthalpy that is possibly a proxy for the degree of crystallinity. This study also observes changes in orientation and/or density due to segmental relaxation during the first heat, thus complementing other characterization methods that measure relaxation or reorganization transitions. Semiconducting materials exhibit very large melt expansion and a richer phase‐behavior compared to commodity polymers, presumably due to their complex chemical structure. The results delineate an important and novel structure‐function relation that, together with simulations constrained by these results, will lead to better rational design of semi‐conducting materials.

Insights into the Thermal Expansion of Amorphous Polymers

An Effective Temperature Theory for the Nonequilibrium Behavior of Amorphous Polymers

Thermo-mechanics of Amorphous Shape-memory Polymers

Modeling the Effect of Physical Aging on the Stress Response of Amorphous Polymers Based on a Two-Temperature Continuum Theory

A Thermodynamic-Consistent Model for the Thermo-Chemo-Mechanical Couplings in Amorphous Shape-Memory Polymers

An Experimental Study on Strain Hardening of Amorphous Thermosets: Effect of Temperature, Strain Rate, and Network Density

Melt Expansion and Thermal Transitions of Semiconducting Polymers in Thin Films

Investigation by molecular dynamics simulation of the glass transition temperature and elastic properties of amorphous polymers PMMA, PMAAM and PMMA co PMAAM copolymers

Retrospecting the relationship between interlamellar amorphous structure and intrinsic modulus of semicrystalline polymers via in-situ positron annihilation lifetime spectroscopy and in-situ X-ray scattering

Unoccupied space and short-range order characterization in polymers under heat treatment

Influence of ensemble boundary conditions (thermostat and barostat) on the deformation of amorphous polyethylene by molecular dynamics

Interactions between Crystalline and Amorphous Domains in Semicrystalline Polymers: Small-Angle X-ray Scattering Studies of the Brill Transition in Nylon 6,6

Interfacial Characteristics Of Amorphous Polystyrene And Binary Polymer Blend Thin Films Based On Scanning Force Microscopy

Chain Conformation Change Upon Heating For Pauci-Chain Polystyrene Microsphere Made By Microemulsion Polymerization

Study on the crystalline structure transition of syndiotactic polystyrene film during heat treatment by two-dimensional infrared correlation spectroscopy.

Direct Imaging of Interfacial Fluctuations in Confined Block Copolymer with in Situ Slow-Scan-Disabled Atomic Force Microscopy

Fundamentally Intertwined: Anharmonic Intermolecular Interactions Dictate Both Thermal Expansion and Terahertz Lattice Dynamics in Molecular Crystals

The viscoelastic and anelastic responses of amorphous polymers in the vicinity of the glass transition temperature

MEAN-SQUARE RADIUS OF GYRATION AND DIPOLE MOMENT OF POLY(METHYLPHENYLSILOXANE) CHAINS

Interfacial molecular structure and orientation evolution of the polystyrene under confinement during annealing revealed by sum frequency generation vibrational spectroscopy

Dynamics of High Molecular Weight Cylindrical And Lamellar Block Copolymers with X‐ray Photon Correlation Spectroscopy (XPCS)