Abstract:In order to find a more effective way to obtain docosahexaenoic acid (DHA) rich lipid from Schizochytrium sp., a widespread propionate wastewater (PW) is used. PW is a common industrial and domestic wastewater, and transforming it into valuable products is a potential treatment method. Schizochytrium sp. is a rapidly growing oleaginous organism, which has been used commercially for DHA production. Herein, PW is completely used for DHA production by Schizochytrium sp. by genetic engineering and fermentation optimization, which can alleviate the increasingly tense demand for water resources and environmental pollution caused by industrial wastewater. Firstly, the methylmalonyl‐CoA mutase (MCM) was overexpressed in Schizochytrium sp. to enhance the metabolism of propionate, then the engineered strain of OMCM can effectively use propionate. Then, the effects of PW with different concentration of propionate were investigated, and results showed that OMCM can completely replace clean water with PW containing 5 g/L propionate. Furthermore, in the fed‐batch fermentation, the OMCM obtained the highest biomass of 113.4 g/L and lipid yield of 64.4 g/L in PW condition, which is 26.8% and 51.7% higher than that of WT in PW condition. Moreover, to verify why overexpression of MCM can promote DHA and lipid accumulation, the comparative metabolomics, ATP production level, the antioxidant system, and the transcription of key genes were investigated. Results showed that ATP induced by PW condition could drive the synthesis of DHA, and remarkably improve the antioxidant capacity of cells by enhancing the carotenoids production. Therefore, PW can be used as an effective and economical substrate and water source for Schizochytrium sp. to accumulate biomass and DHA. This article is protected by copyright. All rights reserved

High-value utilization of the waste hydrolysate of Dioscorea zingiberensis for docosahexaenoic acid production in Schizochytrium sp.

Production of high docosahexaenoic acid by Schizochytrium sp. using low-cost raw materials from food industry

Development of a green fermentation strategy with resource cycle for the docosahexaenoic acid production by Schizochytrium sp.

Enhanced fatty acid storage combined with the multi-factor optimization of fermentation for high-level production of docosahexaenoic acid in Schizochytrium sp.

Enhancing the biomass and docosahexaenoic acid‐rich lipid accumulation of Schizochytrium sp. in propionate wastewater

Enhancement of Docosahexaenoic Acid Production by Low-Energy Ion Implantation Coupled with Screening Method Based on Sudan Black B Staining in Schizochytrium Sp.

Enhancing docosahexaenoic acid production from Schizochytrium sp. by using waste Pichia pastoris as nitrogen source based on two-stage feeding control

Development of an alternative medium via completely replaces the medium components by mixed wastewater and crude glycerol for efficient production of docosahexaenoic acid by Schizochytrium sp

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Improving Docosahexaenoic Acid Productivity of Schizochytrium Sp by A Two-Stage Aemr/Shake Mixed Culture Mode

Development of Schizochytrium sp. strain HS01 with high-DHA and low-saturated fatty acids production by multi-pronged adaptive evolution

Potential utilization of waste sweetpotato vines hydrolysate as a new source for single cell oils production by Trichosporon fermentans.

Electroporation-induced mutation and transcriptome analysis for high DHA production in Schizochytrium limacinum GCD2032

Co-production of DHA and squalene by thraustochytrid from forest biomass

Enhancement of lipid accumulation and docosahexaenoic acid synthesis in Schizochytrium sp. H016 by exogenous supplementation of sesamol

Selectively superior production of docosahexaenoic acid in Schizochytrium sp. through engineering the fatty acid biosynthetic pathways

Docosahexaenoic acid production of the marine microalga Isochrysis galbana cultivated on renewable substrates from food processing waste under CO 2 enrichment

Stain improvement of docosahexenoic acid producing by protoplast mutagenesis

The best utilization of D. zingiberensis C.H. Wright by an eco-friendly process.

Efficient co-production of EPA and DHA by Schizochytrium sp. via regulation of the polyketide synthase pathway

A promising clean process for production of diosgenin from Dioscorea zingiberensis C. H. Wright