Moisturizing strategy for enhanced convective drying of mushroom slices

Zi-Liang Liu,Magdalena Zielinska,Xu-Hai Yang,Xian-Long Yu,Chang Chen,Hui Wang,Jun Wang,Zhongli Pan,Hong-Wei Xiao

DOI: https://doi.org/10.1016/j.renene.2021.03.066

IF: 8.7

2021-07-01

Renewable Energy

Abstract:<p>Moisturizing strategy that controls the water evaporation rate of the wet material and thus the relative humidity in the drying chamber was proposed for hot air drying of mushroom slices for the first time. To assess the effectiveness of moisturizing strategy, drying kinetics, moisture diffusivities, mass transfer coefficients, surface color and rehydration capacity of dried products, energy and exergy efficiencies were evaluated. Mushroom slices were dried at constant drying temperature of 60 °C and air velocity of 3 m/s. The strategies of moisturizing for 0, 15, 30, and 45 min were applied in the initial drying stage. Compared to the continuous dehumidifying strategy (moisturizing time is 0 min), the strategies of moisturizing for 15 and 30 min reduced drying time by 5% and 15%, respectively. The proper moisturizing time (30 min) enhanced the heat transfer by increasing the enthalpy of the drying air, improved surface color, and increased rehydration capacity of dried mushroom slices by reducing cell shrinkage. The energy utilization and energy utilization ratio of drying process varied from 0.16 to 3.48 kJ/s and 0.065 to 0.572, respectively, while the exergy efficiency varied from 8.04% to 84.66%. The strategy of moisturizing for 30 min reduced 23.4% total energy utilization compared to continuous dehumidifying strategy. Both the highest average energy utilization ratio, i.e. 0.156 and average exergy efficiency, i.e. 70.19% were obtained for moisturizing time of 30 min. The increase of moisturizing time from 30 to 45 min showed an adverse impact on drying time, energy utilization ratio, exergy loss, and exergy efficiency due to the inhibition of water evaporation. This study shows that moisturizing strategy can be considered as a promising method to enhance energy and exergy efficiency of hot air dryer with the improvement of products quality and sustainability of drying systems.</p>

energy & fuels,green & sustainable science & technology

What problem does this paper attempt to address?

The paper aims to address the issues of low energy efficiency and poor product quality in the hot air drying process of mushroom slices. Specifically, the study proposes a humidification strategy to control the moisture evaporation rate of wet materials in the drying chamber, and thereby control the relative humidity, to improve energy utilization efficiency and product quality during the hot air drying process. By applying different humidification times (0, 15, 30, and 45 minutes) at the initial stage of drying, the study found that an appropriate humidification time (e.g., 30 minutes) can reduce drying time, improve heat transfer efficiency, enhance product surface color, and increase the rehydration capacity of dried mushroom slices. However, excessively long humidification times (e.g., 45 minutes) can adversely affect drying time and energy utilization. Experimental results show that the 30-minute humidification strategy performs best in terms of energy utilization rate and exergy efficiency, reducing total energy consumption by 23.4% compared to the continuous dehumidification strategy. Therefore, the humidification strategy is proven to be a promising method to enhance the energy efficiency and product quality of hot air dryers.

Moisturizing strategy for enhanced convective drying of mushroom slices

A Novel Phase Change Coolant Promoted Quality Attributes and Glutamate Accumulation in Postharvest Shiitake Mushrooms Involved in Energy Metabolism

Optimization of a variable-temperature heat pump drying process of shiitake mushrooms using response surface methodology

Validation and Optimization of Heat and Mass Transfer Model for Mushroom Convection Drying

Comparison of Freeze-Drying with Three Different Combinations of Drying Methods and Their Influence on Colour, Texture, Microstructure and Nutrient Retention of Button Mushroom (Agaricus bisporus) Slices

Oyster mushroom drying in tray dryer: Parameter optimization using response surface methodology, drying kinetics, and characterization

Shiitake mushroom drying using belt-conveyor combined microwave-hot air and hot air techniques: Drying kinetics, energy consumption, and quality characteristics

Comparison of different drying techniques for shiitake mushroom (Lentinus edodes): Changes in volatile compounds, taste properties, and texture qualities

Numerical Study on the Variable-Temperature Drying and Rehydration of Shiitake

Impact of Dehydration Techniques on the Nutritional and Microbial Profiles of Dried Mushrooms

Relative humidity control during shiitake mushroom (Lentinus edodes) hot air drying based on appearance quality

Improving of texture and rehydration properties by ultrasound pretreatment for infrared-dried shiitake mushroom slices

Influence of a hybrid drying combined with infrared and heat pump dryer on drying characteristics, colour, thermal imaging and bioaccessibility of phenolics and antioxidant capacity of mushroom slices

ANALYSIS OF THE EXISTING METHODS AND SPECIFIC FEATURES OF DRYING SHIITAKE MUSHROOMS

Effects of different drying methods on the product quality and volatile compounds of whole shiitake mushrooms

Cold Plasma Pretreatment – A Novel Approach to Improve the Hot Air Drying Characteristics, Kinetic Parameters, and Nutritional Attributes of Shiitake Mushroom

Dehydration and Quality of Dried Mushrooms: A Review

Effects of different drying treatments on the microstructure, free amino acids, volatile compounds and antioxidant activity of Flammulina velutipes root

Influence of Ultrasonic Pretreatments on Microwave Hot-air Flow Rolling Drying Mechanism, Thermal Characteristics and Rehydration Dynamics of Pleurotus Eryngii.

Optimization of Osmotic Dehydration of White Mushrooms by Response Surface Methodology for Shelf-Life Extension and Quality Improvement of Frozen End-Products

Effects of combined drying techniques and cellulase hydrolysis on the nutritional value and sensory properties of shiitake mushrooms (Lentinus edodes)