Abstract:This study investigates the alternative of replacing noble metals by base metals as catalysts for selective hydrogenation of polyunsaturated hydrocarbons. Nickel catalysts are active for this type of reaction, but poorly selective. However, former calculations anticipated that Ni–Zn alloys could have higher selectivity to alkenes than monometallic Ni depending on the Ni/Zn atomic ratio in the alloy. In this contribution, Ni–Zn alloy nanoparticles supported on TiO2 are synthesized as catalysts for selective hydrogenation of acetylene and butadiene. The designed catalysts with 0.5 wt% Ni loading and various Ni/Zn nominal ratios are prepared by deposition–precipitation with urea (DPU). STEM-HAADF imaging coupled with EDS analysis reveals that Ni–Zn bimetallic particles are formed after reduction treatment at 450 °C. Alloying Ni with Zn leads to a slight increase in the average particle size and a broadening of the size distribution compared to monometallic Ni. However, the average Ni/Zn atomic ratio measured by EDS in the bimetallic particles is always higher than the nominal one, which could be due to Zn evaporation under the beam. The results of acetylene hydrogenation show that although the catalytic activity is slightly reduced after alloying Ni with Zn, the selectivity to ethylene is enhanced from 50% up to 85%, at the expense of the formation of oligomers (coupling products). However, the bimetallic Ni–Zn catalysts suffer from progressive deactivation in this reaction. During butadiene hydrogenation performed in the presence of an excess of propene, the bimetallic Ni–Zn/TiO2 catalysts are significantly more stable, with a high and constant selectivity to butenes (> 95%), compared with Ni/TiO2, which deactivates rapidly in the first hours. Some hypotheses concerning the observed differences in catalytic stability are discussed.

Zinc modification of Ni-Ti as efficient NixZnyTi1 catalysts with both geometric and electronic improvements for hydrogenation of nitroaromatics

Regulating the Microenvironments and the D-Band Center of Hierarchical Nimos/Ts-1 Catalyst by Zro2 to Enhance the Hydrodesulfurization Performance of Dibenzothiophene

Co,N-Codoped Porous Carbon-Supported CoyZnS with Superior Activity for Nitroarene Hydrogenation

NiO x -promoted Cu-based catalysts supported on AlSBA-15 for chemoselective hydrogenation of nitroarenes

Atomically dispersed Ni as the active site towards selective hydrogenation of nitroarenes

Construction of isolated Ni sites on nitrogen-doped hollow carbon spheres with Ni–N3 configuration for enhanced reduction of nitroarenes

Bimetallic Ni–Zn/TiO2 catalysts for selective hydrogenation of alkyne and alkadiene impurities from alkenes stream

Ni-based nanocatalyst protected by ultrathin mesoporous nitrogen-doped carbon layer with hollow structure for the efficient transfer hydrogenation of halogenated nitrobenzenes

Pd-promoting reduction of zinc salt to PdZn alloy catalyst for the hydrogenation of nitrothioanisole

Nanostructured Ni-MoCx: An efficient non-noble metal catalyst for the chemoselective hydrogenation of nitroaromatics

In Situ-Formed Cobalt Nanoparticles Embedded Within Carbonaceous Matrix As Highly Efficient and Selective Catalysts for the Hydrogenation of Nitroarenes

Synergistic catalysis by a hybrid nanostructure Pt catalyst for high-efficiency selective hydrogenation of nitroarenes

Pt Single Atoms Embedded in the Surface of Ni Nanocrystals As Highly Active Catalysts for Selective Hydrogenation of Nitro Compounds.

Foam Ti supported Pd catalysts for the selective hydrogenation of nitroaromatics

Modulating the Catalytic Behavior of Non-Noble Metal Nanoparticles by Inter-Particle Interaction for Chemoselective Hydrogenation of Nitroarenes into Corresponding Azoxy or Azo Compounds

Selective Hydrogenation of Naphthalene over γ-Al2O3-Supported NiCu and NiZn Bimetal Catalysts

Effective Ensemble of Pt Single Atoms and Clusters over the (Ni,Co)(OH) 2 Substrate Catalyzes Highly Selective, Efficient, and Stable Hydrogenation Reactions

Quasi Pd1Ni single-atom surface alloy catalyst enables hydrogenation of nitriles to secondary amines

Quasi Pd 1 Ni single-atom surface alloy catalyst enables hydrogenation of nitriles to secondary amines.

Controlled Electron Transfer at the Ni-ZnO Interface for Ultra-Fast and Stable Hydrogenation of N-propylcarbazole

Room-temperature Hydrogenation of Halogenated Nitrobenzenes over Metal—organic-Framework-derived Ultra-Dispersed Ni Stabilized by N-doped Carbon Nanoneedles