Abstract:<p>The local phase distribution of adiabatic air-water two-phase flow in churn-turbulent to annular flows was experimentally investigated using the Two-Sensor Droplet-Capable Conductivity Probe. The experiments were performed in a 2.54 cm inner diameter vertical round pipe at downward flows. Twelve flow conditions in churn-turbulent to annular flows were chosen for the current study. The inlet superficial gas velocity ranged from 5.68 m/s to 17.19 m/s, and the inlet superficial liquid velocity ranged from 1.21 m/s to 2.64 m/s. The DCCP-2 is able to distinguish droplets, liquid ligaments, bubbles, and continuous gas. The radial profiles of volume fraction, frequency, axial interfacial velocity, and chord length of droplets, ligaments and bubbles were measured. The experimental results showed that gas volume fraction had a center-peak distribution, and the maximum gas volume fraction in centerline could exceed 95%. The volume fraction of droplets was very low, only on the order of 0.1 %. Droplet concentration also showed a center-peak distribution. Both ligament and bubble volume fraction showed a near-wall peak distribution. The ligament volume fraction in the near wall region could reach 80%, which indicated the existence of a film region near the wall and likely includes surface waves on the film. The volume fraction profile of gas, droplets, ligaments, and bubbles showed the tomography structure in churn-turbulent to annular flows. The effects of flow conditions on phase distribution were also studied. An interesting feature was that both the increase of gas flux and the increase of liquid flux tended to increase the bubble volume fraction. The statistical distribution of droplet size was found to be invariant of radial position. The droplet velocity at centerline was generally larger than the superficial gas velocity, which can be attributed to the gravitational effects at downward flows.</p>

Experimental Investigation of the Performance of a Novel Adiabatic Swirl-Flow Separation Apparatus in Air–Water Two-Phase Flow

Design and Simulation of Supersonic Swirling Separator

Experimental Study on Two Different Gas-Liquid Separators Under Different Flow Patterns

Simulation research on the flow field performance of the supersonic separator for natural gas

NUMERICAL STUDY ON SWIRLING FLOW AND SEPARATION PERFORMANCE OF SWIRL VANE SEPARATOR

Experimental investigation on separation characteristics of axial cyclone separator

Experimental Study on Two-Phase Separation Performance of Impacting T-junction

SUPERSONIC SWIRLING SEPARATORS

Study on characteristics of phase-isolation caused by different classic axial flow swirlers in upward vertical gas-liquid two-phase flow

Investigation of two phase liquid jet ejector with simultaneous air and water suction in fresh water distillation system

Experimental Study and Similarity Analysis of Separation Efficiency of Swirl-Vane Separator

Experiment for Partial Reflux Axial-Flow Cyclone Separator with Two-Stage Separation

Joule-Thomson effect and flow behavior for energy-efficient dehydration of high-pressure natural gas in supersonic separator

Passive Control of Gas–liquid Flow in a Separator Unit Using an Apertured Baffle in a Parallel-Flow Condenser

Experimental Investigation on the Separation Characteristics of the Novel Combined Separator

Numerical and Experimental Study on a New Separation Device for Gas-Solid Two-Phase Flows

Evaluation of dynamic behaviors in varied swirling flows for high-pressure offshore natural gas supersonic dehydration

Separation of high velocity wet gas by phase-isolation and split-flow method

Experimental Research on Liquid-Vapor Two-Phase Flow Separation of Zeotropic Mixtures at an Impacting T-junction

Experimental research and numerical analysis for effect of drainage structure on separation performance and the "blockage" of fluid in nozzle

Experimental study of two-phase flow structure in churn-turbulent to annular flows