Abstract:The expansive clay soils, which cover most of the new urbanized areas in Egypt, create major damages in most of the engineering structures and infrastructures such as buildings, roads, bridges, pipelines and others due to bad human activities, e.g. lack of maintenance for sewage and drinking lines, and flood irrigation of golf areas which causes fluctuation of water content through the foundation clay layers associated with shrink-swell behavior. These geotechnical challenges and their treatment solutions consume most of the urbanized project budget and delay the development plan. Therefore, in this study the high plasticity and soft to firm clay soils were stabilized using various dosages of fresh cement kiln dust (CKD) as an economical alternative to the other expensive stabilizing agents (stabilizers or binders) such as lime, cement and other chemical stabilizers. The effectiveness of this type of CKD as a stabilizing agent, soil stabilization mechanism, and changes in mineralogical and microstructural characteristics of stabilized soils due to this stabilization process were evaluated through Atterberg limits, unconfined compressive strength (UCS), stiffness (stress–strain behavior, Es), pH, electrical conductivity (EC), total dissolved solids (TDS), X-Ray diffraction (XRD) and scanning electron microscope (SEM) investigations. The present study revealed that by adding CKD, the workability of the treated clays was increased by decreasing the liquid limit and plasticity index as well as increasing the bearing capacity and decreasing the settlement by increasing UCS and Es. This study also showed that by adding CKD, the initial pH, EC, and TDS of CKD-clay system increased, creating favorable conditions for dissolution of edges and surfaces of clay flakes. The active montmorillonite clay flakes adsorbed the soluble calcium cation and sulfate anion on their surfaces that are rich in soluble silica and alumina and then the cation exchange and flocculation–agglomeration processes began. With curing, the pozzolanic products grew on the surfaces and edges of clay flakes and extended into the voids of the agglomerated inter-clay particles resulting in the filling of these micro-voids. The present investigation also found that, the progressive decreasing in pH, EC, and TDS values of CKD-clay systems through different curing periods is a good indicator for pozzolanic activity.

Hydro-mechanical performance of lime-treated heavy clay incorporating Athel leaves powder

Measured effects on engineering properties of clayey subgrade using lime–Homra stabiliser

The Impact of Moisture and Clay Content on the Unconfined Compressive Strength of Lime Treated Highly Reactive Clays

The stabilisation of clayey soil by using sawdust and sawdust ash

Effect of lime mud under wet grinding on the compressive strength and hydration of cement mortar

Comprehensive evaluation of carbonation and leaching reactions in lime stabilised soils

Effect of polypropylene fibre and lime admixture on engineering properties of clayey soil

Effects of dolomite powder on properties of environment-friendly cement asphalt emulsion composites

Behaviour and Microstructural Characteristics of Lime-GGBS-Treated Kaolin Clay Contaminated with Gypsum

Effect of electric arc and ladle furnace slags on the strength and swelling behavior of cement-stabilized expansive clay

Enhancing clayey soil performance with lime and waste rubber tyre powder: Mechanical, microstructural, and statistical analysis

Expansive and Compressibility Behavior of Lime Stabilized Fiber-Reinforced Marine Clay

Effectiveness of fresh cement kiln dust as a soil stabilizer and stabilization mechanism of high swelling clays

Use of glutinous rice slurry for reducing compressibility and cracking potential of kaolin and lime-treated kaolin

Improvement of Marine Clay Soil Using Lime and Alkaline Activation Stabilized with Inclusion of Treated Coir Fibre

Experimental Study on the Influence of Alccofine-1203 and Phosphogypsum on the Strength Characteristics of Expansive Soil

Integrating lignosulphonate and hydrated lime for the amelioration of expansive soil: A sustainable waste solution

Effect of hydration on pore structure and physical properties of Permian basalt and tuff in Sichuan Basin during pressurized imbibition

Analysis of Strength Development and Soil–Water Characteristics of Rice Husk Ash–Lime Stabilized Soft Soil

The Utilization of Lime-Dried Sludge As Resource for Producing Cement

Improving landfill liner performance with bentonite-slag blend permeated with ammonia for a Municipal solid waste landfill