Abstract:The presence of excessive residual recrystallization structure in the aero-structural part of the Al-Zn-Mg-Cu alloy negatively affects its strength and stress corrosion resistance . To achieve higher service performance, it is significant to reveal the recrystallization behavior of the Al-Zn-Mg-Cu alloy during hot working and subsequent heat treatment. In this work, the isothermal compression tests of an Al-Zn-Mg-Cu alloy were performed at the temperature range 300–450 °C and strain rate range 0.01–10 s −1 . The subsequent heat treatment of the deformed specimens was conducted. The microstructure was characterized by EBSD and XRD techniques. The natural logarithm of Zener-Hollomon parameter (lnZ) was introduced, which increases with the increasing strain rate and decreasing temperature. During hot deformation, CDRX was identified to be the predominant DRX mechanism at high lnZ values, the corresponding recrystallization volume fraction was approximately 15 %. However, at low lnZ values, DDRX becomes the dominant mechanism, the corresponding recrystallization volume fraction was only around 5 %. Moreover, a kinetics analysis was conducted using a low proportion DRX model coupled with lnZ. By comparing the results obtained from finite element simulations with experimental findings, this model was proved to accurately predict the volume fraction of DRX during hot deformation. During the heat treatment process, due to the substantial storage of deformation energy, a significant portion (up to 84.5 %) of SRX was observed under high lnZ conditions. As the lnZ value decreases, the SRX weakens. This weakening is significant enough that under high temperature and low strain rate, the occurrence of SRX becomes extremely unlikely, which can be attributed to the low storage of deformation energy.

Dynamic recrystallization mechanisms and microstructure evolution of a novel Al-Zn-Mg-Cu-Zr alloy by isothermal compression

Dynamic recrystallization mechanisms of as-forged Al–Zn–Mg-(Cu) aluminum alloy during hot comp.ression deformation

Deformation Behavior and Dynamic Recrystallization of a Mg–Zn–Y–Zr Alloy

Hot Deformation Behavior and Microstructure Evolution of a Novel High-Zn Containing Al-Zn-Mg-Cu-Zr Alloy

Dynamic Precipitation and Recrystallization Mechanism During Hot Compression of Mg-Gd-Y-Zr Alloy

The Interactions Between Dynamic Precipitates and Dynamic Recrystallization in Mg-5Zn-1Mn Alloys During Hot Compression

Dislocation Mechanism for Dynamic Recrystallization in Twin-Roll Casting Mg-5.51Zn-0.49Zr Magnesium Alloy During Hot Compression at Different Strain Rates

Study of rotational dynamic recrystallization during warm compression of an Mg-Zn-Nd-Zr alloy

Dynamic recrystallization and precipitation behavior of a novel Sc, Zr alloyed Al-Zn-Mg-Cu alloy during hot deformation

Dynamic precipitation behavior before dynamic recrystallization in a Mg-Zn-Mn alloy during hot compression

Microstructural Study of a Mg-Zn-Zr Alloy Hot Compressed at a High Strain Rate

Hot deformation behavior and dynamic recrystallization mechanism of Ti 2 ZrTa 0.75 refractory complex concentrated alloy

Microstructure evolution mechanisms and a physically-based constitutive model for an Al–Zn–Mg–Cu–Zr aluminum alloy during hot deformation

Hot Deformation and Dynamic Recrystallization Behaviors of Mg–Gd–Y–Zr Alloy

Mechanism of dynamic recrystallization of a FeCrAl alloy during hot compression

Recrystallization behavior of an Al-Zn-Mg-Cu alloy during hot deformation and subsequent heat treatment

Hot deformation and dynamic recrystallization in Al-Mg-Si alloy

Dynamic Recrystallization and Deformation Model of Β-Quenched Zr-4 Alloy Subjected to Elevated Temperature Compression

Dynamic Recrystallization Mechanisms During Hot Compression of Mg–Gd–Y–Nd–Zr Alloy

Dynamic recrystallization kinetics in α phase of as-cast Ti–6Al–2Zr–1Mo–1V alloy during compression at different temperatures and strain rates

Constitutive Modeling of Dynamic Recrystallization Kinetics and Processing Maps of Mg–2.0Zn–0.3Zr Alloy Based on True Stress–strain Curves