Abstract:Supercritical CO2 can be used as a heat transfer fluid in a solar receiver, especially for a concentrating solar thermal power tower system. Such applications require better understanding of the heat transfer characteristics of supercritical CO2 in the solar receiver tube in a high temperature region. However, most of the existing experimental and numerical studies of the heat transfer characteristics of supercritical CO2 in tubes near the critical temperature region, and the corresponding heat transfer characteristics in the high temperature region are conducted. In this paper, a three-dimensional steady-state numerical simulation with the standard k-ε turbulent model is established by using ANSYS FLUENT for the flow and heat transfer of supercritical CO2 in a heated circular tube with an inner diameter of 6 mm and a length of 500 mm in the high temperature region. The effects of the fluid temperature (823–1023 K), the flow direction (horizontal, downward and upward), the pressure (7.5–9 MPa), the mass flux (200–500 kg·m–2·s–1) and the heat flux (100–800 kW·m–2) on the convection heat transfer coefficient and Nusselt number are discussed. The results show that the convection heat transfer coefficient increases while Nusselt number decreases nearly linearly with fluid temperature increasing. Both fluid direction and pressure have negligible effects on the convection heat transfer coefficient and Nusselt number. Moreover, the convective heat transfer coefficient and Nusselt number are enhanced greatly with the increasing of mass flux and the decreasing of heat flux, which is more obvious at a higher heat flux. The influences of buoyancy and flow acceleration on the heat transfer characteristics are also investigated. The buoyancy effect can be ignored within the present parameter range. However, the flow acceleration induced by the high heat flux significantly deteriorates the heat transfer preformation. Moreover, eight heat transfer correlations of supercritical fluid in tubes are evaluated and compared with the present numerical data. The comparison indicates that the correlations based on the thermal property modification show better performance in the heat transfer prediction in the high temperature region than those based on the dimensionless number modification. And Nusselt number predicted by the best correlation has a mean absolute relative deviation of 8.1% compared with the present numerical results, with all predicted data points located in the deviation bandwidth of ±20%. The present work can provide a theoretical guidance for the optimal design and safe operation of concentrating solar receivers where supercritical CO2 is used as a heat transfer fluid.

Supercritical CO2 as heat transfer fluid: A review

Molecular Dynamics Method for Supercritical CO2 Heat Transfer: A Review

General Heat Transfer Correlations for Supercritical Carbon Dioxide Heated in Vertical Tubes for Upward and Downward Flows

Study of Convection Heat Transfer of CO2 at Supercritical Pressures During Cooling in Fluted Tube-in-tube Heat Exchangers

Numerical Investigation of Different Heat Transfer Behaviors of Supercritical CO2 in a Large Vertical Tube

Numerical Investigation for Heat Transfer of Supercritical Co2 Cooled in A Vertical Circular Tube

Experimental and Simulation Investigation on Heat Transfer Characteristics of In-Tube Supercritical CO2 Cooling Flow

The review of heat transfer of supercritical fluid

Research of Heat Transfer Characteristics of Supercritical CO2 in Spiral Tube Heat Exchangers

Analysis on heat transfer correlations of supercritical CO 2 cooled in horizontal circular tubes

Correlation evaluation on circumferentially average heat transfer for supercritical carbon dioxide in non-uniform heating vertical tubes

Development of a New Forced Convection Heat Transfer Correlation for CO2 in Both Heating and Cooling Modes at Supercritical Pressures

A Review of Flow and Heat Transfer Characteristics of Supercritical Carbon Dioxide under Cooling Conditions in Energy and Power Systems

A Critical Review on Heat Transfer of Supercritical Fluids

Experimental and Numerical Investigation of Convective Heat Transfer of Supercritical Carbon Dioxide at Low Mass Fluxes

Numerical Investigation on Heat Transfer of Supercritical CO2 in Solar Receiver Tube in High Temperature Region

Flow and Heat Transfer Characteristics of Supercritical CO2 in a Natural Circulation Loop

Special heat transfer characteristics of supercritical CO2 flowing in a vertically-upward tube with low mass flux

Supercritical carbon dioxide heat transfer in horizontal tube based on the Froude number analysis

Experiments and Heat Transfer Correlation Validations of Low-Parameter Region of sCO2 Flow in a Long Thin Vertical Loop

Research on Convection Heat Transfer Character of Super Critical Carbon Dioxide Flows Inside Horizontal Tube