Abstract:A comprehensive numerical and experimental investigation on micrometer-sized water droplet impact dynamics and evaporation on an unheated, flat, dry surface is conducted from the standpoint of spray-cooling technology. The axisymmetric time-dependent governing equations of continuity, momentum, energy, and species are solved. Surface tension, wall adhesion effect, gravitational body force, contact line dynamics, and evaporation are accounted for in the governing equations. The explicit volume of fluid (VOF) model with dynamic meshing and variable-time stepping in serial and parallel processors is used to capture the time-dependent liquid-gas interface motion throughout the computational domain. The numerical model includes temperature- and species-dependent thermodynamic and transport properties. The contact line dynamics and the evaporation rate are predicted using Blake's and Schrage's molecular kinetic models, respectively. An extensive grid independence study was conducted. Droplet impingement and evaporation data are acquired with a standard dispensing/imaging system and high-speed photography. The numerical results are compared with measurements reported in the literature for millimeter-size droplets and with current microdroplet experiments in terms of instantaneous droplet shape and temporal spread (R/D(0) or R/R(E)), flatness ratio (H/D(0)), and height (H/H(E)) profiles, as well as temporal volume (inverted A) profile. The Weber numbers (We) for impinging droplets vary from 1.4 to 35.2 at nearly constant Ohnesorge number (Oh) of approximately 0.025-0.029. Both numerical and experimental results show that there is air bubble entrapment due to impingement. Numerical results indicate that Blake's formulation provides better results than the static (SCA) and dynamic contact angle (DCA) approach in terms of temporal evolution of R/D(0) and H/D(0) (especially at the initial stages of spreading) and equilibrium flatness ratio (H(E)/D(0)). Blake's contact line dynamics is dependent on the wetting parameter (K(W)). Both numerical and experimental results suggest that at 4.5 < We < 11.0 the short-time dynamics of microdroplet impingement corresponds to a transition regime between two different spreading regimes (i.e., for We < or = 4.5, impingement is followed by spreading, then contact line pinning and then inertial oscillations, and for We > or = 11.0, impingement is followed by spreading, then recoiling, then contact line pinning and then inertial oscillations). Droplet evaporation can be satisfactorily modeled using the Schrage model, since it predicts both well-defined transient and quasi-steady evaporation stages. The model compares well with measurements in terms of flatness ratio (H/H(E)) before depinning occurs. Toroidal vortices are formed on the droplet surface in the gaseous phase due to buoyancy-induced Rayleigh-Taylor instability that enhances convection.

Evolution of mass, surface layer composition and light scattering of evaporating, single microdroplets of SDS/DEG suspension. Shrinking droplet surface as the micelles generator

Evaporation of dilute sodium dodecyl sulfate droplets on a hydrophobic substrate

Evaporation-Induced Crystallization of Surfactants in Sessile Multicomponent Droplets

Wettability and evaporation of dilute sodium dodecyl sulfate droplets on gradient micropillar-arrayed non-wetting surfaces

Wettability and evaporation of dilute sodium dodecyl sulfate droplets on micropillar-arrayed non-wetting surfaces

Experimental and Theoretical Investigation of Contact-Angle Variation for Water–ethanol Mixture Droplets on a Low-Surface-energy Solid

Foam Film Stratification, Viscosity, and Small-Angle X-ray Scattering of Micellar SDS Solutions over an Extended Concentration Range (1< c/CMC < 75)

Morphological Transformation of SDS Aggregates in a Deep Eutectic Solvent Above the Fracto-eutectogel to Fluid Transition Temperature

Drying of a Microdroplet of Water Suspension of Nanoparticles: from Surface Aggregates to Microcrystal

Direct measurement of selective evaporation of binary mixture droplets by dissolving materials

Manipulating Nano-suspension Droplet Evaporation by Particle Surface Modification

A molecular dynamics study of free energy of micelle formation for sodium dodecyl sulfate in water and its size distribution.

Surface diagnostics of evaporating droplets of nanosphere suspension: Fano interference and surface pressure.

Micrometer-sized water droplet impingement dynamics and evaporation on a flat dry surface

Coalescence of sessile aqueous droplets laden with surfactant

Electric surface potential of dodecane nano-drops in aqueous solutions of low ioinic strength

Wetting and evaporation behavior of dilute sodium dodecyl sulfate droplets on soft substrates under a direct current electric field

Microfluidic emulsification with a surfactant and a particulate emulsifier: Dripping-to-jetting transitions and drop size scaling

Unsteady Motion of A Single Droplet in Surfactant Solutions

Dilute sodium dodecyl sulfate droplets impact on micropillar-arrayed non-wetting surfaces