Preparation, Characterization, and Release Kinetics of Zanthoxylum bungeanum Leaf Polyphenol–Chitosan Films

Aiguo Luo,Jing Chen,Bianfang Hu
DOI: https://doi.org/10.3390/coatings13071138
IF: 3.236
2023-06-24
Coatings
Abstract:This study aimed to prepare a composite film with antioxidant activity for fruit and vegetable preservation. Polyphenols were extracted from Zanthoxylum bungeanum leaves (ZMP), and their composition was studied. ZMP-chitosan film (ZMP/C-film) was prepared by tape casting and the film properties were evaluated. The results revealed that ZMP was mainly composed of seven components: epicatechin (3.24 mg/g), chlorogenic acid (3.59 mg/g), coumarin acid (1.40 mg/g), ferulic acid (4.36 mg/g), quercetin (7.61 mg/g), quercetin (4.52 mg/g), and kaempferol (2.51 mg/g). The opacity of the film incorporated with ZMP significantly increased by 2.28 times. Flexibility (elongation at break) increased by 72%, while the ZMP/C-films had lower tensile strength (32.15–40.3 MPa). Microstructurally, scanning electron microscopy results indicated that ZMP and Chitosan (CS) were compatible. Fourier transform infrared spectroscopy revealed the formation of a dense structure between ZMP and CS. Analysis of X-ray diffraction indicated a tendency toward an increase in the amorphous characteristic of the ZMP/C-film. The kinetic results of polyphenol release indicate that ZMP release was mainly achieved through the dissolution of CS-based polymer frameworks. The release rate and rate of ZMP in the membrane were highest in 3.0% acetic acid (v/v) (33.62%). The scavenging rates of DPPH and ABTS+ free radicals by the 1 g/dL ZMP/C-film were 0.83 and 0.82 times higher than those of 1.0 mg/mL vitamin C (Vc) under the same conditions. In addition, ZMP/C-film was used for strawberry preservation. When stored at 25 °C for 7 d, the weight loss rate and VC content of strawberries preserved with ZMP/C-film decreased by 23.4% and increased by 14.2% compared to C-film, respectively. ZMP/C-film prolonged the shelf life of strawberries by more than 4 days.
materials science, multidisciplinary,physics, applied, coatings & films
What problem does this paper attempt to address?
The aim of this paper is to develop a composite film with antioxidant activity for the preservation of fruits and vegetables. Specifically, researchers extracted polyphenols (ZMP) from Zanthoxylum bungeanum leaves and combined them with chitosan (CS) to prepare a controlled-release film (ZMP/C-film). Through this film, researchers hope to improve the physical properties and antioxidant capacity of the film, thereby extending the shelf life of fruits and vegetables. ### Main Research Objectives: 1. **Preparation of Composite Film**: Combine polyphenols from Zanthoxylum bungeanum leaves (ZMP) with chitosan (CS) to prepare a composite film with antioxidant activity. 2. **Evaluation of Film Properties**: Characterize the physical properties, mechanical properties, structural features, release properties, and antioxidant activity of the composite film. 3. **Practical Application Testing**: Use strawberries as the experimental subject to test the effectiveness of the composite film in actual food preservation. ### Specific Problems Addressed: - **Insufficient Physical Properties**: Chitosan films (C-films) have some deficiencies in physical properties, such as low strength, poor water permeability, and poor air permeability. By adding polyphenols from Zanthoxylum bungeanum leaves, researchers hope to improve these properties. - **Enhanced Antioxidant Capacity**: Polyphenols from Zanthoxylum bungeanum leaves have significant antioxidant activity, which can reduce food oxidation damage. Researchers hope to enhance the antioxidant capacity of the composite film. - **Extended Shelf Life**: By improving the physical properties and antioxidant capacity of the film, researchers hope to extend the shelf life of fruits and vegetables, reducing spoilage and waste. ### Experimental Methods: 1. **Extraction and Purification of ZMP**: Extract polyphenols from Zanthoxylum bungeanum leaves and analyze their components using high-performance liquid chromatography (HPLC). 2. **Preparation of the Film**: Prepare composite films with different concentrations of ZMP using the casting method. 3. **Performance Characterization**: Test physical properties such as thickness, light transmittance, solubility, tensile strength, and elongation at break. 4. **Release Kinetics Analysis**: Study the release behavior of polyphenols in different media. 5. **Antioxidant Capacity Testing**: Evaluate the antioxidant performance of the film through DPPH and ABTS radical scavenging experiments. 6. **Practical Application Testing**: Use strawberries as the experimental subject to test the effectiveness of the composite film in actual food preservation. ### Results: - **ZMP Component Analysis**: Polyphenols from Zanthoxylum bungeanum leaves are mainly composed of 7 components, including catechin, chlorogenic acid, p-coumaric acid, ferulic acid, quercetin, and kaempferol. - **Film Properties**: The light transmittance of the ZMP/C-film significantly increased, flexibility improved, but tensile strength decreased. - **Release Kinetics**: The release rate of polyphenols was highest in 3% acetic acid solution. - **Antioxidant Capacity**: The DPPH and ABTS radical scavenging rates of the ZMP/C-film were 0.83 times and 0.82 times higher than 1.0 mg/mL vitamin C, respectively. - **Practical Application**: The ZMP/C-film significantly reduced the weight loss rate of strawberries, increased vitamin C content, and extended the shelf life of strawberries by more than 4 days. Through this research, the researchers successfully developed a composite film with excellent antioxidant performance, which is expected to play an important role in the preservation of fruits and vegetables.