Abstract:We report a new methodology for the electromechanical characterization of organic monolayers based on the implementation of dual AC resonance tracking piezo force microscopy (DART-PFM) combined with a sweep of an applied DC field under a fixed AC field. This experimental design allows calibration of the electrostatic component of the tip response and enables the use of low spring constant levers in the measurement. Moreover, the technique is shown to determine both positive and negative piezo response. The successful decoupling of the electrostatic component from the mechanical response will enable more quantitative electromechanical characterization of molecular and biomaterials and should generate new design principles for soft bio-compatible piezoactive materials. To highlight the applicability, our new methodology was used to successfully characterize the piezoelectric coefficient (d 33) of a variety of piezoactive materials, including self-assembled monolayers made of small molecules (dodecane thiol, mercaptoundecanoic acid) or macromolecules (peptides, peptoids), as well as a variety of inorganic materials, including lead zirconate titanate [PZT], quartz, and periodically poled lithium niobate [PPLN]. Due to high differential capacitance, the soft organic monolayers demonstrated exceedingly large electromechanical response (as high as 250 pm V-1) but smaller d 33 piezocoefficients. Finally, we find that the capacitive electrostatic response of the organic monolayers studied are significantly larger than conventional inorganic piezoelectric materials (e.g., PZT, PPLN, quartz), suggesting organic electromechanical materials applications can successfully draw from both piezo and electrostatic responses.

Piezoelectric excitation and acoustic detection of thin film polymer membrane vibrations

A Systematic Method for Characterizing the Elastic Properties and Adhesion of a Thin Polymer Membrane

Novel technique for mechanical characterization of thin polymeric tissue membrane

Study of piezo-induced surface vibration in solids using atomic force probe

Use of Torsional Acoustic Resonators for Microweighing, Polymer Rheology, and Monitoring of Biofilm Formation

A Novel Technique for Mechanical Characterization of Thin Elastomeric Membrane

Dual-Use Strain Sensors for Acoustic Emission and Quasi-Static Bending Measurements

Near-field electrospinning fabrication of piezoelectric polymer microfiber sensors for detection of weak mechanical excitation

Soft Three-Dimensional Microscale Vibratory Platforms for Characterization of Nano-Thin Polymer Films

Probing viscoelastic properties of a thin polymer film sheared between a beads layer and quartz crystal resonator

A Flexible Piezoelectric Device for Frequency Sensing from PVDF/SWCNT Composite Fibers

The use of polyvinylidene fluoride (PVDF) films as sensors for vibration measurement: A brief review

Accurate electromechanical characterization of soft molecular monolayers using piezo force microscopy

Development of a piezo-cantilever transducer and measuring method for evaluation of a temperature-sensitive polymer gel membrane

Dynamics of pressurized ultra-thin membranes

An elastic piezoelectric nanomembrane with double noise reduction for high-quality bandpass acoustics

Flexible and Transparent Flexoelectric Microphone

Acoustophoresis in polymer-based microfluidic devices: modeling and experimental validation

Simple and Robust Microfabrication of Polymeric Piezoelectric Resonating MEMS Mass Sensors

Piezoelectric fiber-composite-based cantilever sensor for electric-field-induced strain measurement in soft electroactive polymer

Wave-Shaped Piezoelectric Nanofiber Membrane Nanogenerator for Acoustic Detection and Recognition