(Invited) in Situ Measurement of Temperature Distributions in Lithium-Ion Cells under Extreme Conditions for Failure Analysis
Guangsheng Zhang,Xiaoniu Du
DOI: https://doi.org/10.1149/ma2018-02/7/486
2018-01-01
ECS Meeting Abstracts
Abstract:Lithium-ion (Li-ion) batteries are susceptible to failures, even thermal runaway, when operating under extreme conditions that exceed safety limits, such as overcharge, overheating and short circuit. Temperature plays an important role in such failures due to its interaction with electrochemical reactions and heat generation (1). With very low thermal conductivity of battery materials (2, 3) and typically non-uniform heat generation under such extreme conditions, the local temperatures inside Li-ion cells can be very different from surface temperature. In situ measurement of temperature distributions in Li-ion cells can be therefore very useful for safety and failure analysis. Various efforts have been reported in measuring Li-ion cells internal temperatures with insightful findings obtained, typically using embedded thermocouples (4-18), RTD (19, 20) or fiber optic sensors (21-23), or via electrochemical impedance (24-27). But most of these studies only address normal operating conditions. In the few studies that address extreme conditions, only one internal temperature sensor was embedded (4, 10, 18), providing very limited information. In this research temperature distributions in Li-ion cells under extreme conditions are measured for detailed failure analysis. The progress will be reported in the presentation. References: K. Shah, V. Vishwakarma and A. Jain, Journal of Electrochemical Energy Conversion and Storage, 13, 030801 (2016). H. Maleki, S. A. Hallaj, J. R. Selman, R. B. Dinwiddie and H. Wang, Journal of The Electrochemical Society, 146, 947 (1999). P. Gotcu, W. Pfleging, P. Smyrek and H. J. Seifert, Physical Chemistry Chemical Physics, 19, 11920 (2017). R. A. Leising, M. J. Palazzo, E. S. Takeuchi and K. J. Takeuchi, Journal of the Electrochemical Society, 148, A838 (2001). K. Onda, T. Ohshima, M. Nakayama, K. Fukuda and T. Araki, Journal of Power Sources, 158, 535 (2006). C. Forgez, D. Vinh Do, G. Friedrich, M. Morcrette and C. Delacourt, Journal of Power Sources, 195, 2961 (2010). Z. Li, J. Zhang, B. Wu, J. Huang, Z. Nie, Y. Sun, F. An and N. Wu, Journal of Power Sources, 241, 536 (2013). S.-J. Lee, C.-Y. Lee, M.-Y. Chung, Y.-H. Chen, K.-C. Han, C.-K. Liu, W.-C. Yu and Y.-M. Chang, Int. J. Electrochem. Sci, 8, 4131 (2013). G. Zhang, L. Cao, S. Ge, C.Y. Wang, C. E. Shaffer and C. D. Rahn, Journal of The Electrochemical Society, 161, A1499 (2014). G. Zhang, L. Cao, S. Ge, C.Y. Wang, C. E. Shaffer and C. D. Rahn, Scientific Reports, 5, 18237 (2015). M. S. K. Mutyala, J. Zhao, J. Li, H. Pan, C. Yuan and X. Li, Journal of Power Sources, 260, 43 (2014). T. Waldmann, S. Gorse, T. Samtleben, G. Schneider, V. Knoblauch and M. Wohlfahrt-Mehrens, Journal of The Electrochemical Society, 161, A1742 (2014). T. Waldmann, G. Bisle, B.-I. Hogg, S. Stumpp, M. A. Danzer, M. Kasper, P. Axmann and M. Wohlfahrt-Mehrens, Journal of The Electrochemical Society, 162, A921 (2015). T. Waldmann and M. Wohlfahrt-Mehrens, ECS Electrochemistry Letters, 4, A1 (2015). S. J. Drake, M. Martin, D. A. Wetz, J. K. Ostanek, S. P. Miller, J. M. Heinzel and A. Jain, Journal of Power Sources, 285, 266 (2015). P. J. Osswald, M. d. Rosario, J. Garche, A. Jossen and H. E. Hoster, Electrochimica Acta, 177, 270 (2015). P. J. Osswald, S. V. Erhard, J. Wilhelm, H. E. Hoster and A. Jossen, Journal of The Electrochemical Society, 162, A2099 (2015). Q. F. Yuan, F. G. Zhao, W. D. Wang, Y. M. Zhao, Z. Y. Liang and D. L. Yan, Electrochimica Acta, 178, 682 (2015). C. Y. Lee, S. J. Lee, M. S. Tang and P. C. Chen, Sensors, 11, 9942 (2011). G. Zhang, S. Ge, T. Xu, X. G. Yang, H. Tian and C. Y. Wang, Electrochimica Acta, 218, 149 (2016). S. Novais, M. Nascimento, L. Grande, M. F. Domingues, P. Antunes, N. Alberto, C. Leitao, R. Oliveira, S. Koch, G. T. Kim, S. Passerini and J. Pinto, Sensors (Basel), 16 (2016). T. Amietszajew, E. McTurk, J. Fleming and R. Bhagat, Electrochimica Acta, 263, 346 (2018). G. Yang, C. Leitão, Y. Li, J. Pinto and X. Jiang, Measurement (2013). R. Srinivasan, B. G. Carkhuff, M. H. Butler and A. C. Baisden, Electrochimica Acta, 56, 6198 (2011). R. Srinivasan, Journal of Power Sources, 198, 351 (2012). J. P. Schmidt, S. Arnold, A. Loges, D. Werner, T. Wetzel and E. Ivers-Tiffée, Journal of Power Sources, 243, 110 (2013). L. H. J. Raijmakers, D. L. Danilov, J. P. M. van Lammeren, M. J. G. Lammers and P. H. L. Notten, Journal of Power Sources, 247, 539 (2014).