Abstract:Wastewater containing chemical energy and water resources is supposed to be efficiently recovered and utilized. However, conventional wastewater treatment, which is energy intensive and costly, focuses on the degradation of pollutants but ignores the reuse of resources. This study explored the feasibility of integrating wastewater treatment with biofuel production by oleaginous yeasts Rhodosporidium toruloides for sustainability concerns. Aerobic fermentation of R. toruloides was used to treat synthetic sugar-containing wastewater (SSCW) and synthetic sugar-containing wastewater anaerobic fermentation broth (SSCW-AFB). Flux balance analysis (FBA) was used to explore the optimal metabolic flux distributions for lipid production, and the potential of R. toruloides to utilize acetic acid was studied through metabolic network analysis for the first time. Sequencing batch cultivation was used to enhance nutrient removal and microbial lipid accumulation, achieving 87.0 +/- 2.4% and 61.0 +/- 0.1% total organic carbon (TOC) removal coupled with 30.6 +/- 1.1% and 73.5 +/- 0.7% lipid content in SSCW and SSCW-AFB, respectively. The in silico results revealed that nicotinamide adenine dinucleotide phosphate (NADPH)-producing flux of R. toruloides grown on acetic acid preferred going through malic enzyme related pathways rather than the pentose phosphate pathway, resulting in less 15.6% CO2 emissions which in turn facilitates the lipid accumulation. Consistent with the model predictions, a higher lipid coefficient (147.0 mg/g acetic acid) was achieved in SSCW-AFB compared with that in SSCW (105.3 mg/g glucose) during the bioprocess. Furthermore, the lipid production performance under a low seed cell density (0.4 g/L) was significantly better than that under a high seed cell density (4 g/L). Analysis of the biofuel properties indicated the suitability of using SSCW and SSCW-AFB as feedstocks for the industrial production of biodiesel. The results of this study provide valuable information for promoting resource and energy recovery and reducing carbon emission during the wastewater biological treatment process by oleaginous microorganisms.

Culture strategies for lipid production using acetic acid as sole carbon source by Rhodosporidium toruloides

Culture Strategies for Lipid Production Using Low-cost Carbon Sources by Rhodosporidium Toruloides

Enhanced lipid production by Rhodotorula glutinis CGMCC 2.703 using a two‐stage pH regulation strategy with acetate as the substrate

Lipid Production by Rhodosporidium Toruloides Y4 Using Different Substrate Feeding Strategies.

Biodiesel Production of Rhodosporidium Toruloides Using Different Carbon Sources of Sugar-Containing Wastewater: Experimental Analysis and Model Verification

Microbial Lipid Production by Rhodosporidium Toruloides in a Two-Stage Culture Mode

C/N ratio and carbon source-dependent lipid production profiling in Rhodotorula toruloides

High-density Cultivation of Oleaginous Yeast Rhodosporidium Toruloides Y4 in Fed-Batch Culture

[Lipid Synthesis by an Acidic Acid Tolerant Rhodotorula Glutinis].

Optimising nutrients in the culture medium of Rhodosporidium toruloides enhances lipids production

Optimized culture medium and fermentation conditions for lipid production by Rhodosporidium toruloides]

Enhanced Lipid Accumulation in Metschnikowia Pulcherrima Using Volatile Fatty Acids under Non-Sterile Repeated Batch Cultivation

Continuous self-provided fermentation for microbial lipids production from acetate by using oleaginous yeasts Cryptococcus podzolicus and Trichosporon porosum

Renewable Microbial Lipid Production from Oleaginous Yeast: Some Surfactants Greatly Improved Lipid Production of Rhodosporidium Toruloides

Efficient conversion of acetate into lipids by the oleaginous yeast Cryptococcus curvatus

Enzyme-assisted extraction of lipids directly from the culture of the oleaginous yeast Rhodosporidium toruloides.

Optimization of Culture Conditions for Lipid Production by Rhodosporidium toruloides

Sequential bioconversion of C1-gases (CO, CO2, syngas) into lipids, through the carboxylic acid platform, with Clostridium aceticum and Rhodosporidium toruloides

Bioconversion of glycerol into lipids by Rhodosporidium toruloides in a two-stage process and characterization of lipid properties

Comparison of heterotrophic and mixotrophic Chlorella pyrenoidosa cultivation for the growth and lipid accumulation through acetic acid as a carbon source

Biodiesel Production with Microbial Lipid