Abstract:Torrefaction is a potential pretreatment method to produce biochar used as a solid fuel or as an environmentally friendly construction material. However, the torrefaction performance varies when wood composition and mineral content change. Potassium (K) is an abundant mineral present in plants and is claimed to influence the degradation of lignocellulosic biomass. Therefore, a full understanding of the role of potassium is required to predict torrefaction behavior. Samples of beech, celluloses, hemicelluloses, and lignin were impregnated with different potassium carbonate K2 CO 3 concentrations (0.004, 0.008, and 0.012 M). Thermogravimetric analysis was utilized to analyze their thermal degradation characteristics under different temperatures. At 250 °C, the catalytic effect of potassium was weak. At 300 °C, potassium acted as a catalyst until a precise mass loss (65 wt%) and torrefaction duration (105 min) promoted char formation. The changed effect of this weight loss was possibly related to the relative increase in lignin content compared to cellulose and hemicelluloses While at a higher temperature (380 °C), the catalytic effect of potassium was rapid, and the increased char content was better observed. The potassium was found to act mainly on cellulose and hemicelluloses. After pyrolysis, the char weight increased with K up to 25.86 and 15.23 % for heating rates of 10 and 20 K.min −1 , respectively. FTIR and XRD showed that potassium did not significantly impact the structure or the crystallinity of wood at ambient conditions. The obtained results provide a novel insight into the role of potassium in the thermal treatment of biomass, with a better understanding of the thermal degradation mechanisms. This information could help to reduce the operating time and/or temperature, thus rendering torrefaction a green method for waste wood valorization.

Characterization of the decomposition behaviors of catalytic pyrolysis of alkaline lignin with the addition of different concentrations of potassium

Effect of potassium on thermogravimetric behavior and co-pyrolytic kinetics of wood biomass and low density polyethylene

Effect of potassium on the pyrolysis of biomass components: Pyrolysis behaviors, product distribution and kinetic characteristics

Catalytic and char-promoting effects of potassium on lignocellulosic biomass torrefaction and pyrolysis

Hydropyrolysis characteristics and kinetics of potassium-impregnated pine wood

Experimental and theoretical study of the catalytic effects of potassium and calcium additives on the pyrolysis of β-O-4 type lignin model compounds

Effect of Potassium Salts on Biochar Pyrolysis

Catalytic Effect of Alkali Metal Ions on the Generation of CO and CO2 during Lignin Pyrolysis: A Theoretical Study

Effect of various potassium agents on product distributions and biochar carbon sequestration of biomass pyrolysis

Revealing the Anion-Dependent Effects on Potassium-Assisted Biomass Pyrolysis

The new insight about mechanism of the influence of K2CO3 on cellulose pyrolysis

A New Insight into Chemical Reactions Between Biomass and Alkaline Additives During Pyrolysis Process

Influence of inherent alkali metal chlorides on pyrolysis mechanism of a lignin model dimer based on DFT study

Pyrolysis kinetics of potassium-impregnated rubberwood analyzed by evolutionary computation

Pyrolysis of Potassium-Doped Wood at the Centimeter and Submillimeter Scales

Experimental and modeling study of potassium catalyzed gasification of woody char pellet with CO2

Catalysis Mechanism Study of Potassium Salts on Cellulose Pyrolysis by Using TGA-FTIR Analysis

Catalytic Effects of Potassium Concentration on Steam Gasification of Biofuels Blended from Olive Mill Solid Wastes and Pine Sawdust for a Sustainable Energy of Syngas

Effect of Cellulose–Lignin Interactions on Catalytic Pyrolysis over Formate Salt Catalysts

Study on Catalytic Properties of Potassium Carbonate During the Process of Sawdust Pyrolysis

Influence of inherent hierarchical porous char with alkali and alkaline earth metallic species on lignin pyrolysis