Abstract:Immiscible fluid–fluid displacement in porous media is an important phenomenon that impacts the field of underground energy and environmental engineering, such as enhanced oil/gas recovery, geological CO2 sequestration, and transport and remediation of groundwater pollutants. In enhanced oil recovery, the occurrence of the fingering instability of the two-phase flow interface causes a significant reduction in the oil recovery factor for waterflooding. In geological CO2 sequestration, the efficiency of CO2 capillary/residual trapping is limited by the noncompact displacement pattern, presenting only part of brine displaced by scCO2. Although extensive studies have investigated viscous and capillary fingering in porous media, how viscous and capillary forces affect the crossover is not well understood. Quantifying and characterizing the transition of immiscible fluid–fluid displacement patterns are therefore important. In this article, comprehensive investigation of capillary number and viscosity ratio effects on displacement patterns and efficiency was established by a series of displacement microfluidic experiments in a homogeneous pore network. Three pairs of nonwetting–wetting immiscible fluids with viscosity ratios M ranging from 1/1000 to 1000 were used to perform the displacement experiments. The drainage experiments of water displacing silicone oil were conducted under five flow rate conditions with capillary number log10 Ca ranging from −7.19 to −3.45, while the imbibition experiments of silicone oil displacing water displayed at four flow rates with log10 Ca varying from −7.25 to −2.52. The relationship between displacement efficiency S inv and fractal dimension D f as a function of M and Ca was established to quantitatively determine the transition of displacement patterns (capillary fingering, viscous fingering, stable displacement, and ordered dendritic). The results indicated that D f increased with S inv under unfavorable conditions (M < 1) and decreased as S inv for M > 1, and lower invading fluid saturations were observed in the crossover zone between capillary fingering and viscous fingering for M = 1/20 and 1/200. Based on the pore-scale analysis of pore-filling events and microscopic observation, the theoretical model of the transitions for invasion modes were proposed to determine the critical capillary corresponding to viscosity ratio and contact angle. This study extends the classic log10 M–log10 Ca phase diagram and quantifies the dynamic effects of capillary force and viscous force on the immiscible fluid–fluid displacement process.

Trapping and mobilization of residual fluid during capillary desaturation in porous media

Diffusion Hysteresis in Unsaturated Porous Media: A Microfluidic Study

Pore-scale experimental investigation of capillary desaturation in fractured porous media

Dynamics of Fluid Displacement in Mixed-Wet Porous Media

Direct Numerical Simulation of Pore-Scale Trapping Events During Capillary-Dominated Two-Phase Flow in Porous Media

Mobilization of a trapped non-wetting fluid from a three-dimensional porous medium

Saturation dependence of mass transfer for solute transport through residual unsaturated porous media

The Interplay Between Pore‐Scale Heterogeneity, Surface Roughness, and Wettability Controls Trapping in Two‐Phase Fluid Displacement in Porous Media

Percolation without trapping: how Ostwald ripening during two-phase displacement in porous media alters capillary pressure and relative permeability

Wettability stabilizes fluid invasion into porous media via nonlocal, cooperative pore filling

Immiscible fluid displacement in porous media with spatially correlated particle sizes

Modeling of Chemical Tracers to Estimate Oil Volume Contacted and Sweep Efficiency in Porous Media Under Countercurrent Spontaneous Imbibition

Capillary Instability Induced Gas-Liquid Displacement in Porous Media: Experimental Observation and Pore Network Model

Pore scale investigation on scaling-up micro-macro capillary number and wettability on trapping and mobilization of residual fluid

Comparison of CO2 trapping in highly heterogeneous reservoirs with Brooks-Corey and van Genuchten type capillary pressure curves

Flow and transport in the vadose zone: On the impact of partial saturation and Peclet number on non-Fickian, pre-asymptotic dispersion

Fluid-fluid displacement in mixed-wet porous media

Effects of Capillary and Viscous Forces on Two-Phase Fluid Displacement in the Microfluidic Model

Effective Constitutive Relations for Simulating CO2 Capillary Trapping in Heterogeneous Reservoirs with Fluvial Sedimentary Architecture

Retaining an Upper Bound for the Capillary Retention of Two-Phase Flow in Porous Media