Abstract:Abstract Magnetorheological elastomer (MRE) is a type of smart material of which mechanical and electrical properties can be reversibly controlled by the magnetic field. In this study, the influence of the magnetic field on the surface roughness of MRE was studied by the microscopic modeling method, and the influence of controllable characteristics of the MRE surface on its friction properties was analyzed by the macroscopic experimental method. First, on the basis of existing studies, an improved mesoscopic model based on magnetomechanical coupling analysis was proposed. The initial surface morphology of MRE was characterized by the W-M fractal function, and the change process of the surface microstructures of MRE, induced by the magnetic interaction between particles, was studied. Then, after analyzing the simulation results, it is found that with the increase in the magnetic field and decrease in the modulus of rubber matrix, the surface of MRE changes more significantly, and the best particle volume fraction is within 7.5%–9%. Furthermore, through experimental observation, it is found that the height of the convex peak on the surface of MRE decreases significantly with the action of the magnetic field, resulting in a reduction in the surface roughness. Consistent with the simulation results, a particle volume fraction of 10% corresponds to a maximum change of 14%. Finally, the macroscopic friction experiment results show that the friction coefficients of MREs with different particle volume fractions all decrease with the decrease in surface roughness under the magnetic field. When the particle volume fraction is 10%, the friction coefficient can decrease by 24.7% under a magnetic field of 400 mT, which is consistent with the trend of surface roughness changes. This shows that the change in surface morphology with the effect of the magnetic field is an important factor in the control of MRE friction properties by magnetic field.

Magnetic-controlled friction behavior of a water-lubricated magnetorheological rubber bearing under boundary lubrication

Integrated Dynamic Characteristics and Application in Semi-Active Dynamic Absorber of Magneto-Rheological Fluids

Friction and Wear of Self-Mated SiC and Si 3 N 4 in Green Water-Based Lubricant

Study on sliding friction characteristics of magnetorheological elastomer—copper pair affected by magnetic-controlled surface roughness and elastic modulus

Experimental and numerical study on surface roughness of magnetorheological elastomer for controllable friction

Study on the Magnetic Field‐Dependent Rolling Friction Coefficient Compensation of Magnetorheological Elastomer–Copper Ball Friction Pair with Wet Interfaces

Influence of Friction on Magnetorheological Effect

Magneto-controlled friction behaviors of magnetorheological elastomers with cosine-shaped surface structure

Experimental study of surface roughness on improving the tribological performance of sealing pairs in magnetorheological damper

Effect of Base Oil Lubrication Properties on Magnetorheological Fluids

DYNAMIC BEHAVIOUR OF SHEAR-TYPE MAGNETORHEOLOGIC GREASE DAMPER ROTOR SYSTEM

Experimental and numerical study of the mixed lubrication under the action of magnetic ionic liquid additives

Influence of magnetic property of test plates on magneto-rheological behavior

Understanding of the Tribological Behaviors of Magnetic Lubrication Particle under Magnetic Field

Experimental study on seismic performance of laminated rubber bearings with friction slipping

Research on the wear characteristics of magnetorheological fluid in sealing interface considering the interaction between surface roughness and magnetic particles

Experimental investigation on the dynamic behaviour of a disk-type damper based on magneto-rheological grease

Analysis of the Lubrication Performance of Bearing with Non-Newtonian Magnetic Fluids with Considering Stress Couple Effect

Experimental Investigation on the Dynamic Behavior of A Disk-Type Damper Based on Magnetorheological Grease

The friction parameter regulation of magnetorheological elastomers by the initial arrangement and evolution of microscopic ferromagnetic particles

Tribological behavior of reciprocating motion between ferromagnetic films coated with polymethylmethacrylate films under magnetic field