Abstract:Abstract Gravity settling represents the main oil-water separation mechanism. Many separation plants rely only on gravity settling with the aid of demulsifiers (direct or reverse breakers) and other chemicals such as water clarifiers if they are required. Yet, other complementary separation methods exist including filtration, flotation, and centrifugation. In terms of results and more specifically with respect to the separated produced-water, the main threshold on its quality is the dispersed oil content. Even with zero discharge and reinjection into hydrocarbon formations, the presence of residual oil in the aqueous phase represents a concern. High oil content results into formation damage and losses in injectivity which necessitates formation stimulations and hence additional operational expenses. In this work, we investigated the effects of different separation techniques on separated water quality. In addition, we studied the impact of enhanced oil recovery (EOR) chemicals on the different separation techniques in terms of efficiency and water quality. Based on the results, we identified potential improvements to the existing separation process. We used synthetic well-characterized emulsions. The emulsions were prepared at the forecast water: oil ratio using dead crude oil and synthetic representative brines with or without the EOR chemicals. To clearly delineate and distinguish the effectiveness of different separation methods, we exacerbated the conditions by preparing very tight emulsions compared with what is observed on site. With that, we investigated three separation techniques: gravity settling, centrifugation, and filtration. First, we used Jar Tests to study gravity settling, then a benchtop centrifuge at two speeds to evaluate centrifugation potential. Finally, for filtration, we tested two options: membrane and deep-bed filtrations. Concerning the water quality, we performed solvent extraction followed by UV analyses to measure the residual oil content as well as light transmission measurements in order to compare the efficiency of different separation methods. The results of analyses suggest that gravity settling was not efficient in removing oil droplets from water. No separation occurred after 20 minutes in every tested condition. However, note that investigated conditions were severe, tighter emulsions are more difficult to separate compared to those currently observed in the actual separation plant. On the other hand, centrifugation significantly improved light transmission through the separated water. Accordingly, we can conclude that the water quality was largely improved by centrifugation even in the presence of EOR chemicals. In terms of filtration, very good water quality was obtained after membrane filtration. However, significant fouling was observed. In the presence of EOR chemicals, filtration lost its effectiveness due to the low interfacial tension with surfactants and water quality became poor. With deep-bed filtration, produced water quality remained good and fouling was no longer observed. However, the benefits from media filtration were annihilated by the presence of EOR chemicals. Based on these results and at least for our case study, we conclude that centrifugation and deep-bed filtration techniques can significantly improve quality of the separated and eventually reinjected water. In terms of the effects of EOR chemicals, the performance of centrifugation is reduced while filtrations are largely impaired by the presence of EOR chemicals. Thereby, integration of any of the two methods in the separation plant will lead to more efficient produced-water reinjection, eliminating formation damage and frequent stimulations. Yet, it is important to note that economics should be further assessed.

Using Refined Formation Water as Chemical Fertilizers: Implication of Oil and Gas Reservoir Wastewater Recycling for Agricultural Purposes

Assessment of chemical and bacteriological status of treated wastewater of the Baraki WWTP (Algeria) for agricultural purposes

Optimization and treatment of wastewater of crude oil desalting unit and prediction of scale formation

A Separation and Desalination Process for Farmland Saline-Alkaline Water

Effect of Hydrocarbon Contaminated Irrigation Water On Some Selected Soil Physical and Chemical Properties of Sudan Savannah Alfisols

Suitability of treated wastewater for irrigation and its impact on groundwater resources in arid coastal regions: Insights for water resources sustainability

Some Chemical Properties of Wastewater from the Pharmaceutical Production Processes in the State Company for Drug and Medical Appliances Samarra

WATER SALINIZATION IN IRAQ AND SOME SUGGESTED SOLUTIONS

Reuse of treated urban wastewater on the growth and physiology of Medicago sativa L. cv. Gea and Petroselinum crispum L. cv. Commun: correlation with oxydative stress and DNA damage

Feasibility of utilizing recycled drainage water in agriculture using an analytical network process (ANP) and geographic information system (GIS)

Examining the efficacy of biological filters in the removal of agricultural pesticides and nutrient elements from agricultural drainage water

Efficacy of various amendments for immobilization of potentially toxic elements in wastewater contaminated soils

Domestic Wastewater Infiltration Process in Desert Sandy Soil and Its Irrigation Prospect Analysis

Geochemical processes, salinity sources and utility characterization of groundwater in a semi-arid region of Iraq through geostatistical and isotopic techniques

Reagentless Preparation of Formation Water for Reservoir Pressure Maintenance System in Low Permeable Oil Reservoirs. Water Ozonation Method

Produced Water Quality: The Effects of Different Separation Methods for Water and Chemical Floods

Sustainable Approach of Turning Oily Produced Water into Slickwater for Unconventional Reservoir Development

Soil fertility and agro-physiological responses of maize (Zea mays) irrigated by treated domestic wastewater by hybrid multi-soil-layering technology

Comprehensive environmental impact assessment and irrigation wastewater suitability of the Arab El-Madabegh wastewater treatment plant, ASSIUT CITY, EGYPT

Study of the possibility of using zeolite and diatomite in the treatment of oil-contaminated wastewater

Problems of previous local treatment wastewater of oil production and their effective solution