Abstract:In this paper, the flotation separation of quartz and feldspar was studied with CaCl 2 as activators and mixed sodium oleate/ dodecylamine (NaOL/DDA) collectors under alkaline condition, and the action mechanism of mixed NaOL/DDA collectors on the quartz and feldspar surfaces were systematically explored. The results of micro-flotation test showed that there were 90.98% quartz and 13.08% feldspar were floated with 0.5 mmol/L CaCl 2 and 2.8 mmol/L mixed NaOL/DDA collectors with molar ratio of 8/1 at pH 10.0. And the artificial mixed minerals flotation manifested these two minerals were able to efficient separation with CaCl 2 and mixed NaOL/DDA collectors at pH 10 ∼ 11. These outcomes indicated that DDA could increase recovery of quartz obviously and reduce about a half dosage of NaOL (from 0.5 mmol/L to 0.25 mmol/L) in flotation under alkaline condition; Meanwhile, mixed NaOL/DDA collectors were able to decreased the flotation separation pH from 12 to 10 on quartz and feldspar. Infrared spectroscopy (FTIR) and X-ray photoelectron spectroscopy (XPS) results revealed that when NaOL collector was added alone, it could adsorb on activated quartz surface but hardly detected on feldspar surface at pH 10. However, they all were found on both quartz and felspar surface when mixed NaOL/DDA collectors were introduced as collectors. Quartz microcrystal balance with dissipation (QCM-D) experiment confirmed that mixed NaOL/DDA collectors showed a higher adsorption mass and more stable adsorption layer on quartz compared with NaOL was introduced as collector alone. In addition, whether CaCl 2 , NaOL or mixed NaOL/DDA, the adsorption mass on quartz sensor were larger than that on feldspar senor, which might cause difference of hydrophobicity on the surface of quartz and feldspar in flotation. The above experiments showed that the mixed NaOL/DDA collectors can significantly improve hydrophobic difference between quartz and feldspar after activating with CaCl 2 and expand the floated pH range of quartz compared with using NaOL as collector alone, which were efficient reagents to separate quartz and feldspar in flotation.

Selective collection performance of an efficient quartz collector and its response to flotation separation of malachite from quartz

Effects of Alkyl Ether Amine and Calcium Ions on Fine Quartz Flotation and Its Guidance for Upgrading Vanadium from Stone Coal

Efficient separation of magnesite and quartz using eco-friendly Dimethylaminopropyl lauramide experimental and mechanistic studies

Differential adsorption of a high-performance collector at solid–liquid interface for the selective flotation of hematite from quartz

Structural modification of hydroxamic acid collectors to enhance the flotation performance of malachite and associated mechanism

Potential application of an eco-friendly amine oxide collector in flotation separation of quartz from hematite

Flotation separation mechanism of malachite from calcite using the pentyl xanthate as the collector

Selective Flotation Separation of Fluorite from Calcite Using Mixed Anionic/cationic Collectors

The effect and mechanism of cinnamic hydroxamic acid as a collector in flotation separation of malachite and calcite

A novel combined collector with superior selectivity for flotation separation of lepidolite from feldspar: Experimental insight and MD simulation

Design and selection of flotation collectors for zinc oxide minerals based on bond valence model

Selective flotation separation of spodumene from feldspar using a novel mixed anionic/cationic collector NaOL/ND13

Adsorption mechanisms of activated surface of quartz and feldspar with mixed NaOL/DDA

Selective separation mechanism of hematite from quartz by anionic reverse flotation: Implications from surface hydroxylation

Improved Quartz Flotation at Low Temperature by Amino Acid Lauryl Lysine as a Novel Green Collector

Flotation performance and adsorption mechanism of 5-hydroxyoctan-4-one oxime to malachite

The selective adsorption and flotation separation of spodumene from feldspar using a novel iron-group multiple ligand collector

Synthesis of a novel hydroxyl quaternary ammonium collector and its selective flotation separation of quartz from hematite

Enhancing lepidolite flotation efficiency with the novel LCJ collector: comparative analysis and mechanistic insights in Jiangxi Province's lepidolite resources

Flotation behavior of oleate and dodecylamine as mixed collector for recovery of lithium and rubidium from low-grade spodumene tailings: Experiment, characterization and DFT calculation

Understanding the Adsorption Mechanism of BTPA, DEPA, and DPPA in the Separation of Malachite from Calcite and Quartz: DFT and Experimental Studies