Functionality of Soy Proteins in Wheat Flour/Soy Isolate Doughs. III. Protein and Lipid Binding During Dough Mixing

S.S. Chen,V.F. Rasper

DOI: https://doi.org/10.1016/s0315-5463(82)72616-1

1982-01-01

Canadian Institute of Food Science and Technology Journal

Abstract:The changes in nitrogen and lipid extractabilities during mixing of soy protein supplemented wheat flour doughs were studied using water or alkali extracted protein isolates in the form of isoelectric protein or proteinates subjected to different drying techniques. The studies were performed on blends at 8% supplementation level in the absence or presence of a surfactant (SSL, Tween 60, Span 65). Nitrogen solubility of the supplemented doughs increased during their mixing to maximum consistency by approximately 11% and 23% when 0.05M acetic acid and phosphate-NaCl buffer (pH 7.6,μ=0.5) were used, respectively. This increase was considerably higher than that measured with unsupplemented dough. Free lipid extractability of supplemented doughs was reduced in average by 36% compared to 62% reduction in unsupplemented control dough. Among the freeze-dried isolates, the strongest tendency to affect the studied extractabilities was displayed by Ca proteinates. The difference between the effect of these proteinates and other freeze-dried isolates was about the same magnitude as that observed between the lower heat status (freeze- or spray dried) and higher heat status (drum dried) material. Though the addition of surfactants influenced the measured extractabilities, the response pattern with respect to the type of isolate remained practically unchanged.