Abstract:The gas-phase oxidative coupling of methanol and dimethylamine (DMA) was investigated using bimetallic gold-based catalysts in a packed bed reactor. The selective coupling reaction yields dimethylformamide (DMF), a useful solvent for many chemical industries. Characterization of AgAu/SiO 2 and PdAu/SiO 2 catalysts reveal changes to the crystal and electronic structures of the metals indicative of predominantly alloyed nanoparticles. These alloy phases catalyze the oxidative coupling reaction of methanol and DMA to proceed with high selectivity towards DMF at low temperatures, whereas monometallic Ag or Pd catalysts are unselective and monometallic Au catalysts are unreactive. For PdAu/SiO 2 catalysts, increasing dilution of Pd in Au during synthesis results in increased gravimetric reaction rates (by 25 times) and rates per mol Pd (by 663 times), until both gravimetric and per Pd rates decrease as Pd is increasingly diluted in Au. These results suggest there is an optimum surface Pd ensemble size for oxidative coupling reactions, and that isolated Pd atoms are likely unreactive for this chemistry. DMF selectivity increases from monometallic Pd to alloyed Pd (from 45% to >75%), consistent with increasing isolation of oxygen rich domains capable of successive C-H cleavages leading to total oxidation products. Kinetic measurements show low reaction orders for the methanol (0-0.2), dimethylamine (0.1-0.5), and oxygen (0.1-0.2) reactants, alluding to high surface coverages. Co-feeding H2O increased the rate of DMF formation, consistent with the increasingly basic surface adsorbates (i.e., hydroxyls) that are most reactive for kinetically relevant oxidative bond cleavages (e.g., C-H cleavage). DFT calculations and microkinetic modelling reveal surfaces of Pd(111) to be covered by surface oxygen and dehydrogenated DMA, the presence of which affect the reaction kinetics. Finally, at temperatures exceeding 448 K, a wide variety of additional products beyond DMF were detected by on-line mass spectrometry, including methyl formate, methyl dimethyl carbamate, and tetraemethyl urea. The observation of additional products provides the possibility that reported catalysts may produce a variety of chemicals in a single reactor depending on operating conditions.

Selective Vapor-Phase Formation of Dimethylformamide via Oxidative Coupling of Methanol and Dimethylamine over Bimetallic Catalysts

Methyl Formate Formation From Methanol Oxidation Using Supported Gold-Palladium Nanoparticles

Boosting Dimethylamine Formation Selectivity in a Membrane Reactor by In Situ Water Removal

Vapour-phase Gold-Surface-mediated Coupling of Aldehydes with Methanol.

Selective oxidation of methanol to methyl formate over bimetallic Au-Pd nanoparticles supported on SiO2

Non‐oxidative conversion of methanol to dimethyl ether, methyl formate and dimethoxymethane over Cu/Hβ catalyst: Tailoring product selectivity

Catalysts and reaction pathways for dehydrogenation and selective oxidation of methanol to methyl formate

Mesoporous Bimetallic Pdcl2-Cucl2 Catalysts for Dimethyl Carbonate Synthesis by Vapor Phase Oxidative Carbonylation of Methanol

Selective Synthesis of Dimethoxymethane via Direct Oxidation of Methanol or Dimethylether on Supported Keggin Structures

Selective Aerobic Oxidation of Methanol in the Coexistence of Amines by Nanoporous Gold Catalysts: Highly Efficient Synthesis of Formamides

Selective N-Methylation of N-Methylaniline with CO2 and H2 over TiO2-Supported PdZn Catalyst

Selective Oxidation of Methanol to Methyl Formate on Gold: The Role of Low-Coordinated Sites Revealed by Isothermal Pulsed Molecular Beam Experiments and AIMD Simulations

Mechanistic Investigation of Dimethyl Carbonate Synthesis Over Palladium Chloride Catalyst

Sustainable Electrosynthesis of N,N-Dimethylformamide Via Relay Catalysis on Synergistic Active Sites

Synergistic Pd‐Au Catalyst for Selective Electrosynthesis of Dimethyl Carbonate in Conjunction with High‐Rate Redox System

Fuel 110-Poly(Ethylene Glycol)-Supported Phosphonium Halides In Combination With Inorganic Bases/Peg For Highly Efficient Synthesis Of Dimethyl Carbonate From Methanol, Propylene Oxide, And Co2

Efficient Synthesis of Polyoxymethylene Dimethyl Ethers on Al-SBA-15 Catalysts with Different Si/Al Ratios and Pore Sizes

Acetone-Treated Au Nanoparticles Supported on CeO2 for the Wet Air Oxidation of Dimethylformamide

Synthesizing Methyl Formate by Methanol Carbonylation Using DMF Promoter

Boosting the catalytic activity via acid-base synergistic effect for CO2 and methanol direct to dimethyl carbonate

High‐efficiency dimethyl adipate hydrogenation for 1,6‐Hexanediol synthesis over the Cu/SiO2 nanoparticles with reasonably modulations of pore structure and dispersion via surface‐assisted method