Abstract:Background: Microalgae have attracted considerable interest due to their ability to produce a wide range of valuable compounds. Pulsed Electric Fields (PEF) has been demonstrated to effectively disrupt the microalgae cells and facilitate intracellular extraction. To increase the commercial viability of microalgae, the entire biomass should be exploited with different products extracted and valorized according to the biorefinery scheme. However, demonstrations of multiple component extraction in series are very limited in literature. This study aimed to develop an effective lipid extraction protocol from wet Scenedesmus almeriensis after PEF-treatment with 1.5 MJ·kgDW-1. A cascade process, i.e., the valorization of several products in row, was tested with firstly the collection of the released carbohydrates in the water fraction, then protein enzymatic hydrolysis and finally lipid extraction. Biomass processed with high pressure homogenization (HPH) on parallel, served as benchmark. Results: Lipid extraction with ethanol:hexane (1:0.41 vol/vol) offered the highest yields from the different protocols tested. PEF-treatment promoted extraction with almost 70% of total lipids extracted against 43% from untreated biomass. An incubation step after PEF-treatment, further improved the yields, up to 83% of total lipids. Increasing the solvent volume by factor 2 offered no improvement. In comparison, extraction with two other systems utilizing only ethanol at room temperature or elevated at 60 °C were ineffective with less than 30% of total lipids extracted. Regarding cascade extraction, carbohydrate release after PEF was detected albeit in low concentrations. PEF-treated samples displayed slightly better kinetics during the enzymatic protein hydrolysis compared to untreated or HPH-treated biomass. The yields from a subsequent lipid extraction were not affected after PEF but were significantly increased for untreated samples (66% of total lipids), while HPH displayed the lowest yields (~ 49% of total lipids). Conclusions: PEF-treatment successfully promoted lipid extraction from S. almeriensis but only in combination with a polar:neutral co-solvent (ethanol:hexane). After enzymatic protein hydrolysis in cascade processing; however, untreated biomass displayed equal lipid yields due to the disruptive effect of the proteolytic enzymes. Therefore, the positive impact of PEF in this scheme is limited on the improved reaction kinetics exhibited during the enzymatic hydrolysis step.

Consecutive extraction of neutral and polar lipids from skipjack tuna ( Katsuwonus pelamis ) byproducts using supercritical carbon dioxide

Subcritical water extraction of lipids from wet algae for biodiesel production

Lipidomic Profiling of Skipjack Tuna (katsuwonus Pelamis) by Ultrahigh-Performance Liquid Chromatography Coupled to High Resolution Mass Spectrometry

Green extraction of marine phospholipids from Conger eel by-product using SC-CO 2 : Lipidomic profiles and biological activities

Sc-CO2 extraction of fish and fish by-products in the production of fish oil and enzyme

Extraction of lipids and astaxanthin from crustacean by-products: A review on supercritical CO2 extraction

Analysis of the lipid extraction performance in a cascade process for Scenedesmus almeriensis biorefinery

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Extraction of Omega-3 Fatty Acids from Atlantic Sea Cucumber (Cucumaria frondosa) Viscera Using Supercritical Carbon Dioxide

Parallel Extraction of Sulfated polysaccharides and Protein Hydrolysate from Skipjack Tuna Head and Their Bioactive and Functional Properties

Recovery of Omega-3-Rich Lipids: Toward the Sustainable Valorization of Sea-Bass Industry Side Streams

Lipid Indexes and Quality Evaluation of Omega-3 Rich Oil from the Waste of Japanese Spanish Mackerel Extracted by Supercritical CO2

Development of a C18 Supercritical Fluid Chromatography-Tandem Mass Spectrometry Methodology for the Analysis of Very-Long-Chain Polyunsaturated Fatty Acid Lipid Matrices and Its Application to Fish Oil Substitutes Derived from Genetically Modified Oilseeds in the Aquaculture Sector

Simultaneous extraction and fractionation of lipids from the microalga Nannochloropsis sp. for the production of EPA-rich polar lipid concentrates

Purification and characterization of an extracellular lipase from Trichosporon sp. and its application in enrichment of omega-3 polyunsaturated fatty acids

Fish Protein Hydrolysate from Sulfated Polysaccharides Extraction Residue of Tuna Processing By‐Products with Bioactive and Functional Properties

Lipophilic extracts isolated from European cranberry bush (Viburnum opulus) and sea buckthorn (Hippophae rhamnoides) berry pomace by supercritical CO2 - Promising bioactive ingredients for foods and nutraceuticals

Characteristics and Application of Lipase from Asian Seabass Liver Fractionated Using Aqueous Two-phase Partition Technique for Defatting Fish Skin before Collagen Extraction

Technical Note: Extraction of Yellowfin Tuna (thunnus Albacares) Orbital Oil by Supercritical Carbon Dioxide

Supercritical CO2 for efficient extraction of high-quality starfish (Asterias rubens) oil

Optimization of fish oil extraction from Lophius litulon liver and fatty acid composition analysis