Abstract:Considering the advantages (e.g. agglomeration mitigation) and disadvantages (e.g. inorganic species catalysis removal) of biomass demineralization, it is valuable to investigate its effects on gasification performance, thus assessing its necessity prior to performing gasification. To accomplish this, corn straw (CS) was demineralized to different degrees with H2O and HCl, respectively. H2O and HCl demineralization behaved different abilities to inorganic species removal. Cellulose and hemicelluloses content decreased, while lignin content increased, especially with HCl demineralization. The experiments were investigated by using a bench-scale downdraft fixed-bed gasifier at 600-800 °C and were further analyzed via thermogravimetric coupled with Fourier transform infrared spectrometry. Demineralization demonstrated a positive effect on gasification at lower temperatures (600-700 °C) for a dominant effect of lignin content and an insignificant effect of inorganic species removal. However, the catalysis of inorganic species increased as the temperature increased, resulting in the highest H2 (11.30 vol%) and CO (16.02 vol%) production of raw CS compared to demineralized CS at 800 °C. Inorganic species had a dual positive effect on CO generation, promoting both CO2 and char generation leading to a higher CO yield following Boundouard reaction, and increasing the formation of active intermediates thus producing more CO. These effects enhanced when the gasification temperature increased. Additionally, inorganic species catalyzed the aromatic rings rearrangement to generate more H2O, thus driving the endothermic Primary water-gas to produce H2. This was also positively correlated with gasification temperature. Therefore, raw CS demonstrated higher H2 and CO production than demineralized CS at a higher gasification temperature. Moreover, the promotion effect of inorganic species on thermal devolatilization of methoxyl groups and Methanation reaction led to the higher CH4 production of raw CS. This research clarifies the effects of biomass demineralization on its gasification and suggests the potential application.

Enhanced thermal dechlorination of low-rank fuels with wet flue gas

Migration and Agglomeration of Chlorine in Dechlorination of Coal-Fired Flue Gas

Chlorine Release from Co-Pyrolysis of Corn Straw and Lignite in Nitrogen and Oxidative Pyrolysis

Effect of n(Na+)/n(Cl-) on Semi-dry Dechlorination in Coal-fired Flue Gas to Realize Zero Emission of FGD Waste Water

The Technology of Coal-fired Flue Gas Dechlorination for Realizing Zero-discharge of Desulfurization Wastewater and Its Influences on Boiler

Experimental study on coal-fired flue gas HCl removal by injecting adsorbent into flue duct

Co-gasification of Acid Hydrolysis Residues and Sewage Sludge in a Downdraft Fixed Gasifier with CaO As an In-Bed Additive

Chemical looping gasification of high nitrogen wood waste using a copper slag oxygen carrier modified by alkali and alkaline earth metals

Effect of FeCl3 combined with biochar as dewatering conditioners on sludge pyrolysis products

Residual carbon from coal gasification fine slag for inducing rice straw hydrothermal carbonization to achieve improved reactivity and wastewater decontamination

CaO hydrated with ethanol solution for flue gas HCl immobilization. Part I: Modification & dechlorination

Removal of Cl- from WFGD Wastewater by Electrocoagulation using Layered Double Hydroxide Compounds as Granule Electrodes

Inhibition on Chloroaromatics During Thermal Conversion Processes of Municipal Solid Waste by Oxygen-Induced Low-Temperature Pre-Dechlorination and Hydrogen-Assisted In-Situ Cl Capture

Assessment of biomass demineralization on gasification: From experimental investigation, mechanism to potential application

Metal Chloride Influence on Syngas Component During Coal Pyrolysis in Fixed-Bed and Entrained Flow Drop-Tube Furnace

Evolution of Chlorine-Bearing Gases During Corn Straw Torrefaction at Different Temperatures

Dechlorination and fuel gas generation in chemical looping conversion of waste PVC over inherently Na/Ca/K-containing bauxite residue-based oxygen carriers

Air and oxy-fuel incineration disposal of invasive biomass water lettuce (Pistia stratiotes L.): performance, kinetics, flue gas emissions, mechanisms, and ash characteristics

Research progress of hot gas filtration, desulphurization and HCl removal in coal-derived fuel gas: A review

Fundamental study of the behavior of chlorine during the combustion of single RDF

CaO-Assisted Alkaline Liquid Waste Drives Corn Stalk Chemical Looping Gasification for Hydrogen Production