Abstract:Ferrous-based acidogenic fermentation (AF) as a means to treat waste activated sludge (WAS) and produce short-chain fatty acids (SCFAs) has drawn increasing attention, but the massive amount of “iron sludge” that it produces not only significantly increases costs and difficulty of disposal but also poses risks to the environment and human health. This study explored a novel approach to not only reduce the iron dosage required by AF but also to improve its performance by introducing a thiosulfate (TS)–assisted Fe2+/persulfate (TAFP) pretreatment. Effects of the TAFP pretreatment on WAS disintegration and biodegradability, SCFA production, and microbial community structure with different persulfate-Fe2+-thiosulfate molar ratios at 4:4:0 (R1), 4:3:1 (R2), 4:2:2 (R3) and 4:1:3 (R4) were investigated. The results showed that the TAFP pretreatment by a remarkable margin promoted the disintegration of WAS as well as the biodegradability of the organics released, owing to the production of robust free radicals (SO4•− and •OH) triggered by the thiosulfate and Fe2+ cycles. 48-day AF tests further showed maximum SCFA production, ranging roughly between 1283 and 1395 mg COD/L in the TAFP pretreated samples, much higher than Control (<120 mg/L) and R1 (around 593 mg COD/L). At the meantime, the Fe2+ dosage was reduced by 50% in R3 than that of R1. However, a prolonged lag phase of SCFA generation was observed between days 7 and 25, which was ascribable to the acidic conditions (pH < 4.5) closely related to impaired metabolic activities as well as electron transfer efficiencies and limited activities of acidogenic enzymes (i.e., pyruvate-ferredoxin oxidoreductase). Despite such lag phase, the economic and environmental assessment of AF of TAFP-pretreated WAS had a higher net SCFA yield and less “iron sludge” than either without any pretreatment or with Fe2+/persulfate-only pretreatment.

Iron foam coupled hydrolysis acidification for trichloroacetaldehyde treatment: Strengthening characteristics and mechanism

Degradation of the Earthy and Musty Odorant 2,4,6-Tricholoroanisole by Persulfate Activated with Iron of Different Valences.

Chloroacetaldehyde Removal by Zero Valent Iron Enhanced Hydrolytic Acidification Pretreatment

Effect of dissolved oxygen concentration on iron efficiency: Removal of three chloroacetic acids.

Trichloroacetic acid reduction by an advanced reduction process based on carboxyl anion radical

Removal of Terephthalic Acid in Alkalized Wastewater by Ferric Chloride

Landfill Leachate Pretreatment by Coagulation–flocculation Process Using Iron-Based Coagulants: Optimization by Response Surface Methodology

Effect of Iron Oxide Promoted Sulfated Zirconia on the Oxidative Efficiency of H2O2/O3 for Acetic Acid Degradation in Strong Acidic Water

Inhibition and Removal of Trichloroacetaldehyde by Biological Acidification with Glucose Co-Metabolism.

Acidification Inhibition, Biodechlorination, and Biotransformation of Chlorinated Acetaldehydes on Acidogenic Sludge and Microbial Community Changes.

Advanced reduction processes initiated by oxidative radicals for trichloroacetic acid degradation: Performance, radical generation, and mechanism

Haloacetic Acid Removal by Sequential Zero-Valent Iron Reduction and Biologically Active Carbon Degradation

Removal of Carbon Tetrachloride in Waste Water Using Alkali Catalytic Oxidization Method

Thiosulfate-assisted Fe2+/persulfate pretreatment effectively alleviating iron dose and enhancing biotransformation of waste activated sludge into high-value liquid products

Enhanced electrochemical treatment of humic acids and metal ions in leachate concentrate: Experimental and molecular mechanism investigations

Recycling waste iron-rich algal flocs as cost-effective biochar activator for heterogeneous Fenton-like reaction towards tetracycline degradation: Important role of iron species and moderately defective structures

Improvement of humic acid (HA) removal using a new inorganic–organic composite coagulant: α-costic acid as a modifier of polyaluminum chloride properties

The performance of Fe2+/ClO− system in advanced removal of fulvic acid under mild conditions

Enhanced Thermal Hydrolysis of Sewage Sludge by Introducing Tannic Acid (TA)

Degradation of TAIC by iron-carbon micro-electrolysis

Removal effect of trihalomethanes (THMs) and halogenated acetic acids (HAAs) precursors in reclaimed water by polyaluminum chloride (PACl) coagulation