Abstract:The temporal evolution of ordered gamma prime (L12)-precipitates precipitating in a disordered gamma(f.c.c.) matrix is studied in extensive detail for a Ni-12.5 Al at.% alloy aged at 823 K (550 oC), for times ranging from 0.08 to 4096 h. Three-dimensional atom-probe tomography (3-D APT) results are compared to monovacancy-mediated lattice-kinetic Monte Carlo (LKMC1) simulations, which include monovacancy-solute binding energies through 4th nearest-neighbor distances, for the same mean composition and aging temperature. The temporal evolution of the measured values of the mean radius, <R(t)>, number density, aluminum supersaturations, and volume fraction of the gamma prime(L12)-precipitates are compared to the predictions of a modified version of the Lifshitz-Slyozov-Wagner coarsening model due to Calderon, Voorhees et al. The resulting experimental rate constants are used to calculate the Gibbs interfacial free-energy between the gamma(f.c.c.)- and gamma prime(L12)-phases using data from two thermodynamic databases, and its value is compared to all extant values dating from 1966. The diffusion coefficient for coarsening is calculated utilizing the same rate constants and compared to all extant archival diffusivities, not determined from coarsening experiments, and is demonstrated to be the inter-diffusivity, , of Ni and Al. The monovacancy-mediated LKMC1 simulation results are in good agreement with our 3-D APT data. It is demonstrated that the compositional interfacial width, for the {100} interface, between the gamma(f.c.c.)- and gamma prime (L12)-phases, decreases continuously with increasing aging time and <R(t)>, for the 3-D APT results and monovacancy-mediated LKMC1 simulations, in disagreement with an ansatz intrinsic to the trans-interface diffusion-controlled coarsening model, which predicts the opposite trend for binary alloys.

First-principles study of interfacial boundaries in Ni–Ni3Al

First Principles Study of the Diffusional Phenomena Across the Clean and Re-doped Γ-Ni/γ’-ni3al Interface of Ni-based Single Crystal Superalloy

First-principles studies of Al–Ni intermetallic compounds

Tension-compression asymmetry in Ni/Ni 3 Al interfaces: An atomistic investigation

Theoretical Calculations of the Ideal Strength of Ni, NiAl and Ni3Al in Tension and Shear

First-principles investigation of the Ni-Fe-Al system

Insight into γ-Ni/γ′-Ni3Al interfacial energy affected by alloying elements

First-principles Study of Ni-Al Intermetallic Compounds under Various Temperature and Pressure

First-principles study of atomic ordering in fcc Ni-Cr alloys

Atomistic modeling of the γ and γ′-phases of the Ni–Al system

Structural, Electronic, and Optical Properties of Nial3: First-Principles Calculations

Molecular Dynamics Study on the Interactions of 1/2[110] Edge Dislocations with Voids and Ni3Al Precipitates in FCC Ni

A Hierarchical High-Throughput First Principles Investigation on the Adhesion Work, Interfacial Energy and Tensile Strength of NiTi2 (100)/Α-Al2o3 (0001) Interfaces

Mechanical Response and Plastic Deformation in the B2-NiAl/Fe Interface: Molecular Dynamics Analysis

First-principles Studies of the ∑5 Tilt Grain Boundary Inni3al

Study of the Mechanical and Thermodynamic Properties on NiAl and Ni3Al

A Correlative Four-Dimensional Study of Phase Separation at the Subnanoscale to Nanoscale of a Ni-Al Alloy

Atomistic and continuum study of interactions between super-screw dislocations and coherent twin boundaries in L 12 -structured Ni 3 AI

First-principles studies of the ( 5 tilt grain boundary in Ni

First-Principles Calculation of Nb2AlC/Nb Interfaces

Chemical bonding, thermodynamic stability and mechanical strength of Ni3Ti/α-Al2O3 interfaces by first-principles study