Abstract:Bioglycerol is a major by-product of the biodiesel manufacturing process. Various chemical derivatives from bioglycerol would enhance its economic value. An antifreeze of glycerine acetate was chemically converted from an esterification reaction of bioglycerol with acetic acid. The photocatalyst TiO2/SO42− irradiated with ultraviolet light assisted the chemical conversion reaction. The molar ratio of acetic acid/bioglycerol was varied to obtain the optimum composition of the derived antifreeze product. Different cosolvents were considered to enhance the homogeneous extent between the antifreeze of glycerine acetate and biodiesel, and thus, the anti-freezing effect. The cosolvent/glycerine acetate, at various volumetric ratios from 0 to 0.25 vol.%, was blended into a commercial biodiesel. After 5 vol.% antifreeze of the glycerine acetate/cosolvent mixture of the biodiesel was added to the commercial biodiesel, the fuel properties of the biodiesel were analyzed. The effects of the cosolvent types and the blended volumetric ratio of cosolvent to the antifreeze of glycerine acetate on the fuel properties of the commercial biodiesel were analyzed to determine the optimum cosolvent type and volumetric composition of the cosolvent/glycerine acetate. The experimental results show that the antifreeze of glycerine acetate produced from the reaction of acetic acid/glycerol at a molar ratio equal to 8 under UV-light irradiation appeared to have the lowest freezing point. The UV-light irradiation on the TiO2/SO42− catalyst also caused higher triacylglycerol (TAG) and diacylglycerol (DAG) and lower monoacylglycerol (MAG) formation. In addition, the low-temperature fluidity was the most excellent when the volumetric percentage of the methanol/glycerine acetate was equal to 0.25 vol.%, at which the cold filter plugging point (CFPP) of the biodiesel was reduced from 3 °C for the neat biodiesel to −2 °C for the biodiesel blended with the mixture. In contrast, the effect of adding the antifreeze on the CFPP of the biodiesel was inferior; it was reduced from 3 °C for the neat biodiesel to 1 °C for the biodiesel when butanol cosolvent was added. The increase in the volumetric ratio of cosolvent/antifreeze increased the acid value and cetane index while it decreased the kinematic viscosity and CFPP. The heating value was observed to increase for butanol while decreasing for methanol with the increase in the volumetric ratio of cosolvent/antifreeze. In comparison to butanol, the cosolvent methanol caused a higher cetane index and acid value but a lower kinematic viscosity, heating value, and CFPP of the blended commercial biodiesel.

Effects of Heterogeneous Sulfated Acid Photocatalysts and Irradiation of Ultraviolet Light on the Chemical Conversion and Characteristics of Antifreeze from Bioglycerol

Influences of Cosolvents and Antifreeze Additives Derived from Glycerol through Esterification on Fuel Properties of Biodiesel

Improved Hydrogen Production by Glycerol Photoreforming over Ag2O-TiO2 Nanocomposite Mixed Oxide Synthesized by a Sol-gel Method

Glycerol Esterification of Free Fatty Acids Catalyzed by Zinc Glycerolate for Biodiesel Production from Acidified Palm Oil: Optimization, Kinetic Study, and Process Evaluation

Clarifying solvent effect during photocatalytic glycerol conversion on TiO2/GQD as selective photocatalyst

Zinc Glycerolate: an Unconventional Heterogeneous Catalyst for the Glycerolysis of Fatty Acids in Biodiesel Production

Photoelectrochemical Oxidation of Glycerol to Dihydroxyacetone Over an Acid-Resistant Ta:BiVO 4 Photoanode

Solvent-Free Acetalization of Glycerol with N-Octanal Using Combined Brønsted Acid-Surfactant Catalyst

Ethylene Glycol Purification by Melt Crystallization: Removal of Short-Chain Glycol Impurities

Sustainable upgrading of crude glycerol via ultrasound-reinforced bio-refinery process with oxygen–nitrogen subsistence: Co-application of reusable heterogeneous catalyst

AN EXPERIMENTAL STUDY OF THE PHOTOCATALYTIC HYDROGEN PRODUCTION IN THE LABORATORY-SCALE SET-UP DEPENDING ON THE PROCESS CONDITIONS

Synthesis of Acetylglycerols over Hierarchical Porous Sulfonated Polymeric Solid Acid

Etherification of Biodiesel-Based Glycerol with Bioethanol over Tungstophosphoric Acid to Synthesize Glyceryl Ethers

Glycerol Transformation Through Photocatalysis: A Possible Route to Value Added Chemicals

Microbial Conversion of Biodiesel Byproduct Glycerol to Triacylglycerols by Oleaginous Yeast Rhodosporidium Toruloides and the Individual Effect of Some Impurities on Lipid Production

Synthesis Of Jet Fuel From Glycerol And Tert-Butyl Alcohol Under Microwave Irradiation

Synergistic Effects of Nonthermal Plasma and Solid Acid Catalysts in Thermo-Catalytic Glycerol Dehydration

Inhibitory effect of antioxidants on biodiesel crystallization: Revealing the role of antioxidants

Optimization of crude glycerol purification from grease trap waste biodiesel production: exploring the synergistic effect of mixed extraction alcohols on enhanced glycerol purity

Efficient biodiesel production by sulfonated carbon catalyst derived from waste glycerine pitch via single-step carbonisation and sulfonation

Effective Acid-Catalyzed Transesterification for Biodiesel Production.