High-voltage asymmetric MXene-based on-chip micro-supercapacitors

Yanting Xie,Haitao Zhang,Haichao Huang,Zixing Wang,Zhong Xu,Haibo Zhao,Yuchen Wang,Ningjun Chen,Weiqing Yang
DOI: https://doi.org/10.1016/j.nanoen.2020.104928
IF: 17.6
2020-08-01
Nano Energy
Abstract:<p>On-chip micro-supercapacitors (MSCs) are one of the most promising devices to be integrated into micro-/nano-scale electronic devices for offering sufficient peak power and energy support. However, low operate voltage and limited energy density greatly inhibit their wider practical application. Herein, high-voltage on-chip MSCs based on Ti<sub>3</sub>C<sub>2</sub>T<sub><em>x</em></sub> MXene as a negative electrode and activated carbon as a positive electrode are designed and are simply manufactured via a novel cutting-spraying method. Through solving the excessive polarization of MXene, a single asymmetric on-chip MSCs can deliver a potential window up to 1.6 V in neutral electrolyte (PVA/Na<sub>2</sub>SO<sub>4</sub>), and share a high areal capacitance of 7.8 mF cm<sup>−2</sup> (a stack specific capacitance of 36.5 F cm<sup>−3</sup>) and a greatly improved energy density of 3.5 mWh cm<sup>−3</sup> at a power density of 100 mW cm<sup>−3</sup>, which are much higher than other on-chip energy storage counterparts. Besides, MSCs show an excellent capacity retention (remaining 91.4% after 10 000 cycles). More importantly, MSCs can be easily enlarged as highly integrated array in series and/or in parallel on the silicon wafers. Evidently, this study opens up new avenues for developing high-voltage MXene-based MSCs used in on-chip electronics and portable devices.</p>
materials science, multidisciplinary,chemistry, physical,physics, applied,nanoscience & nanotechnology
What problem does this paper attempt to address?
The problem that this paper attempts to solve is: **On - chip micro - supercapacitors (MSCs) are limited in practical applications due to their low working voltage and limited energy density**. Specifically, traditional on - chip micro - supercapacitors have the following main problems: 1. **Low working voltage**: The working voltage window of most existing on - chip micro - supercapacitors is relatively low, usually below 1.2 V. This greatly limits their use in applications with high - power requirements. 2. **Limited energy density**: Due to the low working voltage, the energy density of these devices is also low and cannot meet the high - energy - density requirements of modern microelectronic devices. 3. **Poor cycle stability**: Some materials are prone to structural changes during long - term charge - discharge processes, resulting in performance degradation and affecting the long - term stability of micro - supercapacitors. To solve these problems, the author designed and constructed a **high - voltage asymmetric MXene - based on - chip micro - supercapacitor**. By introducing Ti₃C₂Tₓ MXene as the negative electrode material and activated carbon (AC) as the positive electrode material, and using a neutral gel electrolyte (PVA/Na₂SO₄), the following improvements were successfully achieved: - **Increasing the working voltage window**: By optimizing the electrode materials and structural design, a single asymmetric on - chip micro - supercapacitor can achieve a working voltage window of up to 1.6 V in a neutral electrolyte. - **Significantly improving energy density and power density**: This micro - supercapacitor exhibits an areal capacitance of 7.8 mF cm⁻² (a stacked specific capacitance of 36.5 F cm⁻³) and achieves an energy density of 3.5 mWh cm⁻³ at a power density of 100 mW cm⁻³, which is much higher than other similar devices. - **Excellent cycle stability**: After 10,000 charge - discharge cycles, the capacitance retention rate is still as high as 91.4%, showing good long - term stability. In addition, this study also shows that these micro - supercapacitors can be conveniently integrated into large - scale arrays and are suitable for use as power sources or energy support units in highly integrated electronic devices and portable devices. Therefore, this study has opened up new avenues for the development of high - performance, high - voltage MXene - based on - chip micro - supercapacitors.