Abstract:Studies have been conducted on L-phenylalanine (L-Phe) production and phenylalanine ammonia lyase (PAL) stabilization in the presence of several optimum effectors and reducing agents under bioconversion of transcinnamic acid (t-CA) conditions during repeated batch operations. L-Phe production was maximized and reuseability of PAL catalyst was extended to eight consecutive cycles (repeated batches) in the presence of optimum effectors (glutamic acid, polyethylene glycol and glycerol), thioglycolic acid and sparging with nitrogen gas. These best optimum bioconversion conditions desensitize the PAL catalyst to substantially elevated higher substrate t-CA concentrations and inhibit inactivation of PAL enzyme over longer reaction periods compared to the control. The fed batch mode operation of bioconversion of total t-CA (300 mM) to L-Phe was superior (65.2%, conversion), comparing with conventional batch and repeated batch (58.4%, conversion) operations after 120 h. Gamma irradiation process was employed to polymerize and crosslink polyvinyl alcohol (PVA) with N,N'-methylene-bisacrylamide (BIS) agent. The use of immobilized PAL biocatalyst containing cells in PVA-BIS copolymer gel carrier produced by radiation polymerization is obviously advantageous with regards to the yield of L-Phe which was increased in average 1.2-fold when compare to those obtained with free cells during optimum bioconversion process. When comparing the magnitudes of gamma irradiation effects on immobilized entrapped yeast cells in PVA-BIS copolymer gel carrier using scanning electron microscopy it was show that yeast cells were protected and capable to overcome these conditions and had normal shape and other features as free (unirradiated) intact yeast cells. Optimum conditions for continuous production of L-Phe by PVA-BIS copolymer carrier entrapped yeast cells in a packed bed column reactor in recycle fed-batch mode were investigated. Under these optimum conditions L-Phe accumulated to concentration 240.1 mM represts a total conversion yield of 80% (w/w) from (300 mM) t-CA after 84 h of reaction process, which was higher than that obtained after 120 h of reaction, 65.2% (w/w) from (300 mM) t-CA with free cells in fed-batch mode. The results also demonstrated that during about 4 weeks of repeated continuous recycle fed batch mode experiments (using immobilized cells in packed bed reactor), the final production of L-Phe concentrations decreased gradually in eight consecutive runs with no sign of breakage or disintegration of the carrier gel beads.

Biotransformation of trans-cinnamic acid to l-phenylalanine: Optimization of reaction conditions using whole yeast cells

Novel stabilization of phenylalanine ammonia-lyase catalyst during bioconversion of trans-cinnamic acid to l-phenylalanine

Rational Engineering of Phenylalanine Accumulation in Pseudomonas taiwanensis to Enable High-Yield Production of Trans-Cinnamate

Production of trans-cinnamic acid by whole-cell bioconversion from l-phenylalanine in engineered Corynebacterium glutamicum

Improvement of whole-cell transamination with Saccharomyces cerevisiae using metabolic engineering and cell pre-adaptation

Structural-based Screening of L-phenylglycine Aminotransferase Using L-phenylalanine As the Optimal Amino Donor: Recycling of L-phenylalanine to Produce L-phenylglycine

Continuous production of L-phenylalanine by Rhodotorula glutinis immobilized cells using a column reactor

Enzymic Conversion of D-Phenylalanine Using Bacillus Megaterium AS1. 127

Production of l-phenylalanine from glucose by metabolic engineering of wild type Escherichia coli W3110

Sustainable synthesis of L-phenylalanine derivatives in continuous flow by immobilized phenylalanine ammonia lyase

Improving regioselectivity of phenylalanine aminomutase from Taxus chinensis by semi-rational mutagenesis for the biocatalytic amination of cinnamates

Screening, Characterization and Utilization of D-amino Acid Aminotransferase to Obtain D-phenylalanine

Engineered Zea mays phenylalanine ammonia-lyase for improve the catalytic efficiency of biosynthesis trans -cinnamic acid and p -coumaric acid

Two-Step Production of Phenylpyruvic Acid from L-Phenylalanine by Growing and Resting Cells of Engineered Escherichia coli: Process Optimization and Kinetics Modeling

Identification and Characterization of an Efficient Phenylalanine Ammonia-Lyase from Photorhabdus luminescens

Synergistic improvement of cinnamylamine production by metabolic regulation

The solvent-tolerant Pseudomonas putida S12 as host for the production of cinnamic acid from glucose

Co-production of 7-chloro-tryptophan and indole pyruvic acid based on an efficient FAD/FADH2 regeneration system

Metabolic engineering and protein directed evolution increase the yield of L-phenylalanine synthesized from glucose in Escherichia coli

Phenylalanine production by metabolically engineered Corynebacterium glutamicum with the pheA gene of Escherichia coli

L-Phenylalanine ammonia-lyase fromPhaseolus vulgaris: Modulation of the levels of active enzyme bytrans-cinnamic acid