Abstract:This paper firstly presents an extended sliding mode observer (ESMO) for the electro-hydraulic servo systems (EHSSs) to deal with nonlinear factors like the external disturbance, parameter uncertainties as well as unmodeled characteristics in the EHSS. The model for the EHSS is established by taking these nonlinear factors into consideration and then the statespace representation is obtained. According to the state space, the ESMO for the EHSS is presented, the equivalence principle is properly utilized to simplify the ESMO and some saturation functions are employed to eliminate high frequency interferences caused by the chattering phenomenon. Based on estimated values from the ESMO, a robust adaptive backstepping controller (RABC) is presented in detail with taking some parameter uncertainties into consideration to further improve the tracking performance. The proposed controller has the following advantages: (1) utilizing the ESMO to cope with these nonlinear factors; (2) parameter online adaptive laws are employed in the RABC design to further improve the tracking performance. In order to verify the performance of the proposed controller, an experiment bench was established. Two sine waves reference signal (one amplitude 0.01 m, 1 Hz; the other 0.015 m, 2 Hz) are employed to verify the performance of the controller. Comparative experimental results show that: (1) the tracking performance of the proposed controller is better than that of a DOs based BC, a BC and a PI controller; (2) estimation values from the ESMO contains fewer noise than two conventional disturbance observers (DOs), which will decrease the control input ripples.

Self-Healing Control for Wastewater Treatment Process Based on Variable-Gain State Observer

EXTENDED DISTURBANCE OBSERVER-BASED SLIDING MODE FAULT-TOLERANT CONTROL FOR THE DUAL-VALVE HYDRAULIC SERVO SYSTEM WITH REDUCED-ORDER MODEL

Objective-oriented Genetic Algorithm Based Dynamical Sliding Mode Control for Slurry Level and Air Pressure in Shield Tunneling

A Scalable-Bandwidth Extended State Observer-Based Adaptive Sliding-Mode Control for the Dissolved Oxygen in a Wastewater Treatment Process

Sensor and Actuator Fault Estimations and Self-healing Control of Discrete-time T-S Fuzzy Model with Double Observers and Its Application to Wastewater Treatment Process

Residual-triggered threshold decision and performance self-healing control for wastewater treatment process

Reinforcement-Learning-Based Tracking Control of Waste Water Treatment Process under Realistic System Conditions and Control Performance Requirements

Performance-guaranteed adaptive self-healing control for wastewater treatment processes

Output Feedback Adaptive Super-Twisting Sliding Mode Control of Hydraulic Systems with Disturbance Compensation

Mode Substitution and Constraint Implementation in Complex Dynamic Process Regulation: A Solution for Performance Self-Recovery

Adaptive neural control of the dissolved oxygen concentration in WWTPs based on disturbance observer

Disturbance Observer-Based Sliding Mode Controller for Underwater Electro-Hydrostatic Actuator Affected by Seawater Pressure

Fixed Time Performance Self-Recovery Control for Dissolved Oxygen Concentration Based on Failure Effect Observation

The Sliding Mode Control of the Drum Water Level Based on Extended State Observer

Fault Effect Identification-Based Adaptive Performance Self-Recovery Control Strategy for Wastewater Treatment Process

A Multi-Objective Direct Heuristic Dynamic Programming Based Tracking Control for Wastewater Treatment Process

Dynamic Surface Intelligent Robust Control of Nonlinear Systems With Fixed-Time Sliding-Mode Observer

Extended sliding mode observer based robust adaptive backstepping controller for electro-hydraulic servo system: Theory and experiment

Sliding mode control of electro-hydraulic servo system based on double observers

Sliding Mode Control Based on High Gain Observer for Electro-Hydraulic Servo System

Modeling and control of wastewater treatment process with time delay based on event-triggered recursive least squares