Abstract:A novel closed‐loop method for Li and Co recovery from a lithium cobalt oxide (LCO) material using a deep eutectic solvent (DES) based on choline chloride (ChCl) and ethylene glycol (EG) with an additional source of protons. This process allowed to quantitatively recover Co and Li, highlighting the importance of adding a precise amount of protons to drive Co dissolution. In addition, the DES was used in three successive leaching/recovery cycles without any degradation. This study evaluates the ability of a choline chloride:ethylene glycol‐based deep eutectic solvent (DES) to dissolve lithium cobalt oxide (LCO) which is used as a cathode active material in Li‐ion batteries. Both a commercial powder and spent cathodes have been used. It was demonstrated that if HCl is added in a small proportion, a rapid and efficient LCO dissolution can be achieved. Indeed, if more than three protons are added per one cobalt atom present in the LCO structure, a complete dissolution of the material is accomplished within 2 h at 80 °C. This result might be considered as a viable alternative compared to the literature where much longer reaction times and higher temperatures are applied to achieve similar results with the same DES system used either pure or in presence of additional reducing agents. It was further demonstrated that Co and Li can be fully precipitated after Li2CO3 addition. This precipitation does neither pollute the DES nor leads to its degradation provided the pH does not exceed 10. Finally, it was shown that two additional reuse cycles can be carried out without any decrease of recovery efficiency, while no degradation products have been detected within the DES phase.

Upcycling spent Lithium-ion battery cathodes to cobalt-polyphenol network by DES dissolution and solvent-induced crystallization

A Universal Molten Salt Method for Direct Upcycling of Spent Ni‐rich Cathode Towards Single‐crystalline Li‐rich Cathode

Efficient Dissolution of Lithium-Ion Batteries Cathode LiCoO2 by Polyethylene Glycol-Based Deep Eutectic Solvents at Mild Temperature

Deep eutectic solvent with acidity, reducibility, and coordination capability for recycling of valuable metals from spent lithium-ion battery cathodes

In Situ Constructed Spinel Layer Stabilized Upcycled LiCoO2 for High Performance Lithium‐Ion Batteries

Efficient Dissolution of Lithium-Ion Batteries Cathode LiCoO 2 by Polyethylene Glycol-Based Deep Eutectic Solvents at Mild Temperature

A Weak Acidic and Strong Coordinated Deep Eutectic Solvent for Recycling of Cathode from Spent Lithium-Ion Batteries

Sustainable Upcycling of Spent LiCoO2 to an Ultra-Stable Battery Cathode at High Voltage

Direct Upcycling of Degraded LiCoO2 Material Toward High‐Performance Single‐Crystal NCM Cathode

Phase-separated solvothermal high yields recovery of lithium and cobalt cathode precursors from end-of-life LiCoO2 lithium-ion batteries

Grave-to-cradle photothermal upcycling of waste polyesters over spent LiCoO2

Recycling lithium cobalt oxide from its spent batteries: An electrochemical approach combining extraction and synthesis

Sustainable upcycling of spent LiCoO<sub>2</sub> to an ultra-stable battery cathode at high voltage

Short-Process Regeneration of Highly Stable Spherical LiCoO2 Cathode Materials from Spent Lithium-Ion Batteries through Carbonate Precipitation

Recycling cathode material LiCo1/3Ni1/3Mn1/3O2 by leaching with a deep eutectic solvent and metal recovery with antisolvent crystallization

Recovery of cobalt from spent lithium-ion battery cathode materials by using choline chloride-based deep eutectic solvent

Lithium‐Ion Battery Cathode Recycling through a Closed‐Loop Process Using a Choline Chloride‐Ethylene Glycol‐Based Deep‐Eutectic Solvent in the Presence of Acid

Mild and efficient recovery of lithium-ion battery cathode material by deep eutectic solvents with natural and cheap components

Sustainable upcycling of mixed spent cathodes to a high-voltage polyanionic cathode material

A Novel Green Process for Recovery of Transition Metal Ions from Used Lithium-ion Batteries by Selective Coordination of Ethanol

Efficient separation and coprecipitation for simplified cathode recycling