Abstract:Spraying dust suppression is a common method for controlling dust pollution in coal mine transportation roadways, and the application of surfactants significantly reduces dust concentration. To clarify the effects of polyether-type nonionic surfactants on coal dust wetting and aggregation, this study investigated the impact of LAE-X (X = 4, 7, 9) surfactants on the wetting and aggregation of TN bituminous coal, as well as the "solid-liquid" interface mechanism, through macroscopic experiments, DFT calculations, and MD simulations. The results show that, at the macroscopic level, the degree of polymerization affects the adsorption configuration of LAE at the gas–liquid interface. LAE-9 exhibits the lowest surface tension due to its high effective adsorption layer density at the interface and better micelle stability in the bulk phase. The wetting effect of LAE-X on TN bituminous coal follows the order: LAE-9 > LAE-7 > LAE-4. At lower degrees of polymerization, wetting is positively correlated with polymerization degree. The adsorption of LAE-X is the fundamental reason for changing the wetting properties of TN bituminous coal. An increase in polymerization degree not only increases the content of OH and oxygen-containing functional groups (OCG), enhancing the adsorption capacity of TN bituminous coal but also allows for the capture and aggregation of fine particles to form larger diameters. At the microscopic level, the molecular orbitals of LAE-X are located on OCG, where OCG provides hydrophilic active sites. The higher the polarity index, the greater the number of hydrogen bonds. The increase in negative electrostatic potential area and uneven electrostatic potential distribution lead to an increase in the MPI value of TN bituminous coal, thereby promoting wetting. The C-O-C interaction strengthens the coal-water interaction, primarily due to changes in the electrostatic potential on the surface of TN bituminous coal, resulting in an increase in the diffusion coefficient and relative concentration of water molecules, with electrostatic interaction energy accounting for approximately 70 %–80 %. Additionally, hydrogen bonding is stronger than van der Waals forces. When selecting or applying surfactants, it is advisable to consider adding polyether types to achieve wetting and dust aggregation in bituminous coal, providing theoretical research and reference for the use of aggregating wetting-type nonionic surfactants in spray dust suppression.

Effect of Gemini surfactant on wettability of Lignite: An experimental and molecular dynamics simulation study

Microscopic adsorption behaviors of ionic surfactants on lignite surface and its effect on the wettability of lignite: A simulation and experimental study

Adsorption Behavior of Surfactant on Lignite Surface: A Comparative Experimental and Molecular Dynamics Simulation Study

Effect of bio-based surfactant on wettability of low-rank coal surface and its mechanism

Study on the effects of surfactants on the interface characteristics and wettability of lignite

Determining the effect of the non-ionic surfactant AEO9 on lignite adsorption and wetting via molecular dynamics (MD) simulation and experiment comparisons

Experimental and molecular dynamics investigations of the effects of ionic surfactants on the wettability of low-rank coal

Molecular dynamics simulation and experimental characterization of anionic surfactant: Influence on wettability of low-rank coal

Characterization of the wetting properties of ionic liquids on lignite surfaces: Molecular dynamics simulations

Molecular mechanism study on the effect of nonionic surfactants with different degrees of ethoxylation on the wettability of anthracite

A microscopic mechanism study of the effect of binary surfactants on the flotation of Wiser bituminous coal

Experimental and molecular dynamics study into the surfactant effect upon coal wettability

Molecular dynamics simulations of nonionic surfactant adsorbed on subbituminous coal model surface based on XPS analysis

Effect of mixed cationic/anionic surfactants on the low-rank coal wettability by an experimental and molecular dynamics simulation

Molecular simulation and experimental study on the wetting and agglomeration of bituminous coal by oligomeric surfactant LAE-X

The Effect of Water Addition on the Surface Energy, Bulk and Flow Properties of Lignite

Study on the mechanism of the influence of surfactant alkyl chain length on the wettability of anthracite dust based on EDLVO theory and inverse gas chromatography

Study on the effects of inorganic salts and ionic surfactants on the wettability of coal based on the experimental and molecular dynamics investigations

Optimizing Coal Wettability via Anionic Surfactants: An Integrated Experimental and Molecular Dynamics Simulation Investigation

The impact of hydrophilic groups in dodecyl surfactants on the regulation of wettability at the anthracite interface

Research on Mechanism of Surfactant Improving Wettability of Coking Coal Based on Molecular Dynamics