Abstract:Background: Microalgae have attracted considerable interest due to their ability to produce a wide range of valuable compounds. Pulsed Electric Fields (PEF) has been demonstrated to effectively disrupt the microalgae cells and facilitate intracellular extraction. To increase the commercial viability of microalgae, the entire biomass should be exploited with different products extracted and valorized according to the biorefinery scheme. However, demonstrations of multiple component extraction in series are very limited in literature. This study aimed to develop an effective lipid extraction protocol from wet Scenedesmus almeriensis after PEF-treatment with 1.5 MJ·kgDW-1. A cascade process, i.e., the valorization of several products in row, was tested with firstly the collection of the released carbohydrates in the water fraction, then protein enzymatic hydrolysis and finally lipid extraction. Biomass processed with high pressure homogenization (HPH) on parallel, served as benchmark. Results: Lipid extraction with ethanol:hexane (1:0.41 vol/vol) offered the highest yields from the different protocols tested. PEF-treatment promoted extraction with almost 70% of total lipids extracted against 43% from untreated biomass. An incubation step after PEF-treatment, further improved the yields, up to 83% of total lipids. Increasing the solvent volume by factor 2 offered no improvement. In comparison, extraction with two other systems utilizing only ethanol at room temperature or elevated at 60 °C were ineffective with less than 30% of total lipids extracted. Regarding cascade extraction, carbohydrate release after PEF was detected albeit in low concentrations. PEF-treated samples displayed slightly better kinetics during the enzymatic protein hydrolysis compared to untreated or HPH-treated biomass. The yields from a subsequent lipid extraction were not affected after PEF but were significantly increased for untreated samples (66% of total lipids), while HPH displayed the lowest yields (~ 49% of total lipids). Conclusions: PEF-treatment successfully promoted lipid extraction from S. almeriensis but only in combination with a polar:neutral co-solvent (ethanol:hexane). After enzymatic protein hydrolysis in cascade processing; however, untreated biomass displayed equal lipid yields due to the disruptive effect of the proteolytic enzymes. Therefore, the positive impact of PEF in this scheme is limited on the improved reaction kinetics exhibited during the enzymatic hydrolysis step.

Comparative analysis of process intensification technologies (PIT) for improved cell disruption and lipid recovery in Aurantiochytrium sp. SW1 microalgae

Combination of cell disruption method and pH variation as pre-treatment for lipid extraction of Nannochloropsis sp.

Cell disruption methods for improving lipid extraction efficiency in unicellular microalgae

Analysis of the lipid extraction performance in a cascade process for Scenedesmus almeriensis biorefinery

A novel rapid ultrasonication-microwave treatment for total lipid extraction from wet oleaginous yeast biomass for sustainable biodiesel production

Harvesting optimization and Omega-3 recovery improvement from Schizochytrium DT3 using surfactant-aided dispersed air flotation: Response surface methodology

Optimization of Cell Disruption and Transesterification of Lipids from Botryococcus braunii LB572

Cell Disruption of Chaetoceros calcitrans by Microwave and Ultrasound in Lipid Extraction

Hydrothermal microwave processing of microalgae as a pre-treatment and extraction technique for bio-fuels and bio-products

Maximizing Lipid Extraction from Chlorella pyrenoidosa: A Study on the Effectiveness of Cell Disruption Techniques

Combined Enzymatic and Mechanical Cell Disruption and Lipid Extraction of Green Alga Neochloris oleoabundans

Optimization of a novel lipid extraction process from microalgae

Effect of different cell disruption methods on lipid yield of Schizochytrium sp.

Lipids extraction from the green alga Ankistrodesmus falcatus using different methods

THE EXTRACTION OF OIL FROM Nannochloropsis sp. MICROALGAE USING ULTRASONIC AND FERMENTATION AS CELL DISRUPTION

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

Ultrasound-Enhanced and Microwave-Assisted Extraction of Lipid from Dunaliella Tertiolecta and Fatty Acid Profile Analysis

Post-incubation pH Impacts the Lipid Extraction Assisted by Pulsed Electric Fields from Wet Biomass of Auxenochlorella protothecoides

Effects of Pulsed Electric Field Treatment on Enhancing Lipid Recovery from the Microalga, Scenedesmus.

Improved Aqueous Extraction of Microalgal Lipid by Combined Enzymatic and Thermal Lysis from Wet Biomass of Nannochloropsis Oceanica.

Optimization of Enzymatic Cell Disruption for Improving Lipid Extraction from Schizochytrium sp. through Response Surface Methodology.