Abstract:Waste cooking oil (WCO) is a readily available and cheap feedstock for biodiesel production. However, WCO contains high levels of free fatty acids (FFAs), which negatively impact the biodiesel yield if homogeneous catalysts are used. Heterogeneous solid acid catalysts are preferred for low-cost feedstocks because the catalysts are highly insensitive to high levels of FFA in the feedstock. Therefore, in the present study, we synthesized and evaluated different solid catalysts, pure β-zeolite, ZnO-β-zeolite, and SO42-/ZnO-β-zeolite for the production of biodiesel using WCO as feedstock. The synthesized catalysts were characterized by Fourier transform infrared spectroscopy (FTIR), pyridine-FTIR, N2 adsorption-desorption, X-ray diffraction, thermogravimetric analysis, and scanning electron microscopy, while the biodiesel product was analyzed using nuclear magnetic resonance (1H and 13C NMR) and gas chromatography-mass spectroscopy. The results revealed that the SO42-/ZnO-β-zeolite catalyst showed excellent catalytic performance for simultaneous transesterification and esterification of WCO, with a higher percentage conversion than the ZnO-β-zeolite and pure β-zeolite catalyst, due to the large pore size and high acidity. The SO42-/ZnO-β-zeolite catalyst exhibits 6.5 nm pore size, a total pore volume of 0.17 cm3/g, and high surface area of 250.26 m2/g. Experimental parameters such as catalyst loading, methanol:oil molar ratio, temperature, and reaction time were varied in order to establish the optimal parameters. The highest WCO conversion of 96.9% was obtained using the SO42-/ZnO-β-zeolite catalyst under an optimum reaction condition of 3.0 wt % catalyst loading, 200 °C reaction temperature, and 15:1 molar ratio of methanol to oil in 8 h reaction time. The WCO-derived biodiesel properties conform to the ASTM6751 standard specification. Our investigation of its kinetics revealed that the reaction follows a pseudo first-order kinetic model, with an activation energy (Ea) of 38.58 kJ/mol. Moreover, the stability and reusability of the catalysts were evaluated, and it was found that the SO42-/ZnO-β-zeolite catalyst exhibited good stability, giving a biodiesel conversion of over 80% after three synthesis cycles.

Biodiesel production from transesterified yellow grease by ZSM-5 zeolite-supported BaO catalyst: process optimization by Taguchi’s experimental design approach

Glycerol Esterification of Free Fatty Acids Catalyzed by Zinc Glycerolate for Biodiesel Production from Acidified Palm Oil: Optimization, Kinetic Study, and Process Evaluation

Synthesis of MgO/ZSM-5 catalyst and optimization of process parameters for clean production of biodiesel from Spirulina platensis

Synthesis of fatty acid methyl ester via transesterification of waste frying oil by a zinc-modified pumice catalyst: Taguchi approach to parametric optimization

Zinc Glycerolate: an Unconventional Heterogeneous Catalyst for the Glycerolysis of Fatty Acids in Biodiesel Production

Biodiesel production through the transesterification of rapeseed oil over CaO‐MgO/SBA‐15 catalysts

Transesterification of Methyl Oleate for Sustainable Production of Biolubricant: Process Optimization and Kinetic Study

Sustainable Biodiesel Production via Biogenic Catalyzed Transesterification of Baobab Oil Methyl Ester and Optimization Process

Investigation of Jatropha Oil Transesterification into Methyl Esters under Supercritical Methanol Environment using Advanced Heterogeneous Catalysts

Comparative study of catalytic conversion of glycerol, a by-product of transesterification, to cyclic hydrocarbons using MCM-22, ZSM-5 and alumina

Production and Optimization of Biodiesel in a Membrane Reactor, Using a Solid Base Catalyst

Preparation and characterization of SrO/MgO nanocomposite as a novel and efficient base catalyst for biodiesel production from waste cooking oil: a statistical approach for optimization

Biodiesel Production from Waste Cooking Oil via β-Zeolite-Supported Sulfated Metal Oxide Catalyst Systems

Optimization and kinetic study of biodiesel production from Jatropha curcas oil in supercritical methanol environment using ZnO/γ-Al2O3 catalyst

Sodium Methoxide/Zeolite-Supported Catalyst for Transesterification of Soybean Waste Cooking Oil for Biodiesel Production

BaO as a heterogeneous nanoparticle catalyst in oil transesterification for the production of FAME fuel

Transesterification of Soybean Oil to Biodiesel Using Zeolite Supported CaO As Strong Base Catalysts

Sustainable production of biodiesel from waste cooking oil using magnesium oxide nano catalyst: An optimization study

Catalytic Cracking of Fatty Acid Methyl Esters for the Production of Green Aromatics Using Zn-Modified HZSM-5 Catalysts

Sulfamic acid modified UiO-66 metal-organic framework for biodiesel production: Process optimization using response surface methodology, kinetics, and thermodynamic study

The Optimization of the Production of Methyl Esters from Corn Oil Using Barium Hydroxide as a Heterogeneous Catalyst