Abstract:Direct discharging of high nitrogen and phosphorus concentration wastewater can bring serious eutrophication to the environment. The activated sludge process has been widely used for solving this problem. However, the process exhibits poor removal of nitrogen and phosphorus due to the shortage of carbon source, and also produces a lot of waste activated sludge (WAS) which needed to be treated and disposed. On the basis of these considerations above, anaerobic fermentation of WAS and fermentation liquid utilization processes were developed. However, fermentation liquid separation from fermented sludge was difficult and had high energy consumption. To avoid the problem of liquid-solid separation difficulty involved in traditional WAS anaerobic fermentation liquid utilization process, the feasibility of using fermentation mixture directly as external carbon source for nitrogen and phosphorus removal of wastewater treatment was discussed. Firstly, the characteristics of anaerobic fermentation mixture under the acidic (pH value of 4), neutral (pH value uncontrolled) and alkaline (pH value of 10) conditions over 90 days were compared. Secondly, biological denitrification and biological phosphorus removal processes by adding alkaline fermentation mixture of different volumes were investigated. A set ofsequencing batch reactors (SBR) were respectively fed with 0.5 L seed sludge and 0.5 L wastewater, and then alkaline fermentation mixture of 0, 10, 20, 30, 50, 100 and 200 mL were added into the 7 reactors. The feasibility of using anaerobic fermentation mixture from WAS under alkaline condition as external carbon source was indicated by nitrate nitrogen (NO3--N) removal efficiency and pure phosphorus release amount.Meanwhile, the influence of ammonia (NH4+-N) concentration on biological nitrification process was analyzed. The results indicated that: 1) Alkaline fermentation mixture showed the best merit of reusable carbon source, with soluble chemical oxygen demand (SCOD) reaching 3428.5 mg/L corresponded to short chain fatty acids (SCFAs) accumulation of 1521.4 mg COD/L. Meanwhile, a small amount of nitrogen (C/N=18.9) and phosphorus (C/P=57.0) was released during alkaline fermentation. 2) The NO3--N removal efficiency was 69.3% when the initial NO3--N concentration was 15.0±0.5 mg/L and the maximum pure phosphorus release amount was 18.5 mg/Lin blank test. Compared with the blank test, the highest NO3--N removal efficiency (100%) occurred with the optimal additive volume of more than 30 mL in biological denitrification process. The maximum pure phosphorus release amount (22.8 mg/L) occurred with the optimal additive volume of 20 mL, 4.3 mg/L higher than that of blank test. However, excessive fermentation mixture could significantly reduce the nitrification rate. The highest NH4+-N removal rate was 0.293 mg/(L·min) with the optimal additive volume of 30 mL in biological nitrification process. When the additive volume was more than 30 mL (50, 100 and 200 mL), the NH4+-N removal rates were 0.244, 0.109 and 0.004 mg/(L·min), respectively. Therefore, the strategy using anaerobic fermentation mixture from WAS under alkaline condition as external carbon source is feasible. It can solve the problems of carbon source lack and WAS disposal, and also simplify the process of traditional WAS anaerobic fermentation liquid utilization. This strategy is suitable for the treatment of rural domestic wastewater with low C/N ratio.

Enhanced biological wastewater treatment supplemented with anaerobic fermentation liquid of primary sludge

Sludge alkaline fermentation enhanced anaerobic- multistage anaerobic/oxic (A-MAO) process to treat low C/N municipal wastewater: Nutrients removal and microbial metabolic characteristics.

Enhanced Anaerobic Treatment of Swine Wastewater with Exogenous Granular Sludge: Performance and Mechanism.

Enhanced biological nutrient removal in a simultaneous fermentation, denitrification and phosphate removal reactor using primary sludge as internal carbon source

Advanced treatment of digested sludge using an aerobic bacterium

Succession Of Bacterial Community In Anaerobic-Anoxic-Aerobic (A(2)O) Bioreactor Using Sludge Fermentation Liquid As Carbon Source

Waste Activated Sludge Alkaline Fermentation Liquid As Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors

Anaerobic Fermentation Mixture from Waste Activated Sludge under Alkaline Condition Improving Treatment Effect of Wastewater with Low C/N

Superior Nitrogen Removal and Efficient Sludge Reduction Via Partial Nitrification-Anammox Driven by Addition of Sludge Fermentation Products for Real Sewage Treatment.

Acidogenic sludge fermentation to recover soluble organics as the carbon source for denitrification in wastewater treatment: Comparison of sludge types

Pilot-scale Waste Activated Sludge Alkaline Fermentation, Fermentation Liquid Separation, and Application of Fermentation Liquid to Improve Biological Nutrient Removal.

Enhanced wastewater treatment with an AnF-AAO system for improved internal carbon source utilization

The Feasibility of Enhanced Biological Phosphorus Removal in the Novel Oxic/extended Idle Process Using Fermentation Liquid from Sludge Fermentation

Enhanced Nutrient Removal and Microbial Community Structure in a Step-feed A2/O Process Treating Low-C/N Municipal Wastewater

Enhanced Nitrogen and Phosphorus Removal in the A2/O Process by Hydrolysis and Acidification of Primary Sludge

Integrated process of Tetrasphaera-dominated in-situ waste activated sludge fermentation, biological phosphorus removal and endogenous denitrification in single reactor for treatment of wastewater with limited carbon sources

Biological Sludge Reduction and Enhanced Nutrient Removal in a Pilot-Scale System with 2-Step Sludge Alkaline Fermentation and A2O Process

Enhanced Nitrogen and Phosphorus Removal from Municipal Wastewater in an Anaerobic-Aerobic-anoxic Sequencing Batch Reactor with Sludge Fermentation Products As Carbon Source.

Promising carbon utilization for nitrogen recovery in low strength wastewater treatment: Ammonia nitrogen assimilation, protein production and microbial community structure.

Experimental research on suspended aerobic biofilm A2O system for treating domestic wastewater

Iron-enhanced Primary Sedimentation and Acidogenic Sludge Fermentation to Achieve Self-Sufficient Organic Carbon Supply for Enhanced Nutrient Removal in Wastewater Treatment✰