Abstract:Introduction: Bacterial contamination of blood products presumably occurs mainly during blood collection, starting from low initial concentrations of 10–100 colony-forming units (CFUs) per bag. As little is known about bacterial growth behavior and distribution in stored whole blood (WB) and WB-derived blood products, this study aims to provide data on this subject. Methods: WB units were inoculated with transfusion-relevant bacterial species ( Acinetobacter baumannii, Bacillus cereus, Escherichia coli, Klebsiella pneumoniae, Listeria monocytogenes, Pseudomonas fluorescens, Serratia marcescens, Staphylococcus aureus, Staphylococcus epidermidis, Streptococcus dysgalactiae, Streptococcus pyogenes, Yersinia enterocolitica ; n = 12 for each species), stored for 22–24 h at room temperature, and then centrifuged for separation into plasma, red blood cells (RBCs), and buffy coats (BCs). The latter were pooled with 3 random donor BCs and one unit of PAS-E each to yield plasma-reduced platelet concentrates (PCs). Samples for bacterial colony counting were collected after WB storage and immediately after blood component production. Sterility testing in PCs ( n = 12 for each species) was performed by bacterial culture after 7 days of storage. Results: Bacterial growth in WB varied remarkably between donations and species. Streptococcus species produced the highest titers in WB, whereas Staphylococcus aureus , Staphylococcus epidermidis , Escherichia coli, and Pseudomonas fluorescens did not multiply. Centrifugation resulted in preferential accumulation of bacteria in BCs, with titers of up to 3.5 × 10 3 CFU/mL in BCs and up to ≤0.9 × 10 3 CFU/mL in BC-derived PCs. Overall, 72/144 PCs (50%) tested positive for bacteria after storage. Sterility test results were species-dependent, ranging from 12 of 12 PCs tested positive for Streptococcus pyogenes to 1 of 12 PCs positive for Escherichia coli . Bacterial contamination of RBC and plasma units was much less common and was associated with higher initial bacterial counts in the parent WB units. Conclusions: Bacterial growth in WB is species-dependent and varies greatly between donations. Preferential accumulation of bacteria in BCs during manufacturing is a critical determinant of the contamination risk of BC-derived pooled PCs.

Posttransfusion Sepsis Attributable to Bacterial Contamination in Platelet Collection Set Manufacturing Facility, United States

Acquired platelet storage container leaks and contamination with environmental bacteria: A preventable cause of bacterial sepsis

Bacterial Contamination of Platelet Products

Bacterial contamination of platelets for transfusion: strategies for prevention

Bacterial contamination of platelets concentrates in a lower middle-income country: Data from a single tertiary care hospital

Prevalence of Multidrug-Resistant Pathogens Causing Neonatal Early and Late Onset Sepsis, a Retrospective Study from the Tertiary Referral Children’s Hospital

Investigating Transfusion-related Sepsis Using Culture-Independent Metagenomic Sequencing

The international experience of bacterial screen testing of platelet components with automated microbial detection systems: An update

Detection of Bacterial Contamination of Apheresis Platelets in a Chinese Blood Center

Bacterial Detection of Platelets: Current Problems and Possible Resolutions

Formation of Single-Species and Multispecies Biofilm by Isolates from Septic Transfusion Reactions in Platelet Bag Model

Bacterial culture of apheresis platelets: a mathematical model of the residual rate of contamination based on unconfirmed positive results

Hemovigilance monitoring of platelet septic reactions with effective bacterial protection systems

Incidence, Distribution and Clinical Relevance of Microbial Contamination of Preservation Solution in Deceased Kidney Transplant Recipients: a Retrospective Cohort Study from China.

Modulation of Staphylococcus aureus gene expression during proliferation in platelet concentrates with focus on virulence and platelet functionality

Proliferation of psychrotrophic bacteria in cold-stored platelet concentrates

Impact of Donor Arm Cleaning with Different Aseptic Solutions for Prevention of Contamination in Blood Bags

Comparable bacterial growth in platelet concentrates suspended in plasma and platelet additive solution and improved detection of bacterial contamination using a new generation automated culture system

Growth and Distribution of Bacteria in Contaminated Whole Blood and Derived Blood Components

Mechanism of cross-contamination of blood culture bottles in outbreaks of pseudobacteremia associated with nonsterile blood collection tubes

A survey of US hospitals on platelet inventory management, transfusion practice, and platelet availability