Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Aerodynamic Interaction Characteristics Study of the Ducted Coaxial Propeller for a Novel eVTOL in Hovering

Aerodynamic Performance and Numerical Analysis of the Coaxial Contra-Rotating Propeller Lift System in eVTOL Vehicles

Conceptual Design and System Level Analysis of Tilt-Duct eVTOL Aircraft

Numerical Simulation and Experimental Study on the Aerodynamics of Propulsive Wing for a Novel Electric Vertical Take-Off and Landing Aircraft

Aerodynamic and aeroacoustics investigation of tandem propellers in hover for eVTOL configurations

Experimental Investigation on Hover Performance of a Ducted Coaxial-Rotor UAV

Deep Learning Based Adaptive Deformation of Aerodynamic Shape for Ducted Propellers

Longitudinal Aerodynamic Characteristics of Ducted Fan Propelled Fixed-Wing VTOL Aircraft Hovering in Ground Effect

Computational Investigation of Blade–Vortex Interaction of Coaxial Rotors for Evtol Vehicles

Experimental Research on Aero-Propulsion Coupling Characteristics of a Distributed Electric Propulsion Aircraft

Aerodynamic Optimization Design of Duct Body Structure for Coaxial Rotor Unmanned Aerial Vehicles

A Conceptual Design and Optimization Approach for Distributed Electric Propulsion eVTOL Aircraft Based on Ducted-Fan Wing Unit

Hovering efficiency optimization of the ducted propeller with weight penalty taken into account

Aerodynamic Simulation of a Typical Multirotor e VTOL Aircraft Configuration.

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

Numerical study on aerodynamic performance of a ducted tail rotor in hover and sideward flight

Influence of Propeller Parameters on the Aerodynamic Performance of Shrouded Coaxial Dual Rotors in Hover

Experimental Analysis of the Aerodynamics of Long-Shrouded Contrarotating Rotor in Hover

An rVPM-Based Aerodynamic Hybrid Optimization Method for Coaxial Rotor with Differentiated Upper and Lower Blades in Both Hover and High-Speed Cruising States

Flight Dynamics Modeling and Simulation of Propeller Deflected Slipstream VTOL Aircraft

Aerodynamic performance assessment of a ducted fan UAV for VTOL applications