Abstract:Innovations in lithium-ion batteries rely crucially on the availability of advanced characterization techniques. High-resolution chemical imaging of low-Z elements e.g., lithium (Li) is often difficult in many conventional chemical analysis techniques such as Energy-Dispersive X-ray Spectroscopy. High-resolution Secondary Ion Mass Spectrometry (SIMS) imaging is a well-known technique for the analysis of all elements including isotopes. For this reason, SIMS imaging is used in numerous studies related to Li-ion battery research. While direct imaging of Li in post-mortem battery components is helpful to understand parts of the degradation mechanisms, a complete dynamic view of the evolution of the Li distribution at high resolution during operation (‘ operando ’) of batteries is required to fully understand the local interfacial processes, charge transport characteristics and the degradation mechanisms. A few reports presenting operando Time-of-Flight SIMS imaging of batteries have recently been published [1], but the lateral resolution demonstrated in these reports is not adequate to study local processes that occur at nanoscale. In order to demonstrate operando SIMS chemical imaging with sub-20 nm lateral resolution, we developed a novel operando methodology suitable for Focused Ion Beam (FIB)-SIMS imaging and analysis (see Fig. 1). An in-house designed magnetic-sector mass spectrometer [2] attached to a ThermoFisher SCIOS Ga + FIB is used for SIMS chemical imaging. A special operando sample holder was designed to enable electrochemical cycling of batteries within the FIB-SIMS instrument. The micromanipulator inside the FIB (typically used for preparing thin lamellae for Transmission Electron Microscopy) is used to contact one of the battery electrodes through the operando sample holder and complete the electrical circuit. An external potentiostat is then connected to the instrument to drive the charging/discharging of batteries. The proof-of-concept experiments were performed using Li|Li 7 La 3 Zr 2 O 12 |Li symmetric half-cells. Galvanostatic cycling was performed in-situ inside the FIB-SIMS instrument until the sample failed. SIMS chemical mapping revealed a redistribution of Li during cycling. Lithium rich phases appeared during cycling which likely percolated through grain-boundaries and pores of the solid electrolyte causing a short-circuit failure. These results validate our methodology for operando analysis of Li-ion batteries with the possibility to obtain SIMS chemical images with sub-20 nm lateral resolution [3]. This work was funded by the Luxembourg National Research Fund (FNR) through the grant INTER/MERA/20/13992061 (INTERBATT). [1] Y. Yamagishi, et al., J. Phys. Chem. Lett. 2021, 12, 19, 4623–4627 [2] O. De Castro, et al., Analytical Chemistry, 2022, 94, 30, 10754–10763. [3] L. Cressa, et al., Analytical Chemistry, 2023, under review. Figure 1

Green Rust: Revealing the Structural Evolution of Green Rust Synthesized in Ionic Liquids by In Situ Molecular Imaging (Adv. Mater. Interfaces 15/2020)

Li-Intercalation Oxides: Atomic-Scale Observation of LiFePO4 and LiCoO2 Dissolution Behavior in Aqueous Solutions (adv. Funct. Mater. 45/2018)

In Situ Atomic-Scale Imaging of Electrochemical Lithiation in Silicon.

Dry Chemistry of Ferrate(VI): A Solvent‐Free Mechanochemical Way for Versatile Green Oxidation

Lithiation of SiO2 in Li-ion Batteries: in Situ Transmission Electron Microscopy Experiments and Theoretical Studies.

Visualization of electrochemically driven solid-state phase transformations using operando hard X-ray spectro-imaging

Controlled Synthesis of Oxidation-Insensitive Green Rust, a Mixed-Valent Iron Mineral, for Enhancing Solar Hydrogen Production via Hydrolysis of Ammonia Borane

Soft X-ray spectromicroscopic proof of a reversible oxidation/reduction of microbial biofilm structures using a novel microfluidic in situ electrochemical device

Recent Advances in Ionic Liquids for Synthesis of Inorganic Nanomaterials

Ionic liquids in green chemistry: Today's solvent or tomorrow's solution?

Single Particle ICP-MS and GC-MS Provide a New Insight into the Formation Mechanisms During the Green Synthesis of AgNPs

Towards Operando Secondary Ion Mass Spectrometry Imaging of Lithium Redistribution in Solid-State Lithium-Ion Batteries: Correlation of Structural, Chemical and Electrochemical Characteristics

Surfactant‐Mediated Crystalline Structure Evolution Enabling the Ultrafast Green Synthesis of Bismuth‐MOF in Aqueous Condition (Small 15/2024)

Controlled Architectures in Supported Photocatalysis: Exploring the Potential of Cold Plasma Discharge, Additive Manufacturing, and Fractal Geometry to Form Hierarchically Immobilized Ni-MOF/BiOI/AgVO 3

In situ monitoring nanoscale solid-state phase transformation of Ag nanowire during electrochemical reaction

Liquid-mediated Ostwald ripening of Ag-based clusters supported on oxides

Liquid-Phase Electrochemical Scanning Electron Microscopy for in Situ Investigation of Lithium Dendrite Growth and Dissolution

Nano-Plasticity of an Electrified Ionic Liquid/Electrode Interface: Uncovering Hard-Soft Structuring via Controlled Metal Fill Factor

Green Synthesis for Battery Materials: A Case Study of Making Lithium Sulfide via Metathetic Precipitation

2D Functional Minerals as Sustainable Materials for Magneto‐Optics (Adv. Mater. 16/2022)

Processing Rusty Metals into Versatile Prussian Blue for Sustainable Energy Storage