Abstract:The growth of high-quality ZnO bulk crystals is an outstanding challenge, and the nature of grown-in defects in crystals is far from well understood. In this work, a specially designed low-temperature-gradient CVT growth system was developed based on finite element analysis. High-quality ZnO single crystals were successfully grown. The supersaturation front in the growth system was controlled, and internal stress in the crystal was reduced by introducing a radiation baffle and a special seed pedestal. The structural, electrical, and optical properties of ZnO crystals were studied before and after oxygen annealing. The scanning electron microscope (SEM) and optical microscope (OM) results indicate the stable growth is achieved under the Zn-rich growth condition. The X-ray rocking curve measurements reveal the high crystalline quality of the grown crystal with the full-width at half-maximum (FWHM) value of 17 arcsec for the (004) reflection. The time-of-flight secondary ion mass spectroscopy (ToF-SIMS) results prove the high purity of grown crystals and reveal the variations of trace impurity concentrations in crystals. When annealed in oxygen at 1000 °C, the optical band gap (Eg) changes from 2.50 eV to 3.15 eV. The Raman analysis indicates that oxygen vacancies (Vo) in the as-grown crystal disappear after annealing. The Hall measurements show that the room temperature (RT) mobilities before and after annealing are 197 cm2V−1c−1 and 207 cm2V−1c−1, respectively. The RT carrier concentration decreases by about two orders of magnitude to 5.45 × 1015 cm−3, while the RT resistivity increases by about one order of magnitude to 5.57 Ω cm after annealing. The positron annihilation lifetimes (PALS) results prove the presence of Zn vacancies (Vzn) after annealing. The origins of as-grown ZnO green luminescence (GL) and the temperature-dependent blue shifts of the GL peak positions are explained based on Zni and Vo defects. The fine structures of annealed ZnO GL are found to be related to Vzn native defects rather than Cu impurity.

Optimized growth and anisotropic properties of Li 2 ZrTeO 6 nonlinear optical crystals

Crystal Growth, Characterization, and Properties of Nonlinear Optical Crystals of Li 0.5 Ag 0.5 GaTe 2 for Mid-Infrared Applications

Crystal growth and thermal properties of a LiY(MoO 4 ) 2 crystal

Growth and spectroscopic characterization of Zr:Fe:LiNbO3 crystals with various Li/Nb ratios

A NEW CRYSTAL GROWTH METHOD FOR THE GROWTH OF NEAR-STOICHIOMETRIC LiNbO3

Growth and characterization of K3Li2−xNb5+xO15+2x single crystals obtained by the edge-defined film-fed growth technique

Improved Blue Photorefractive Properties of Near‐stoichiometric LiNbO3:Mn:Fe:Zr Crystal

Optimal Design of Mid-Infrared Nonlinear-Optical Crystals: From SrZnSnSe 4 to SrZnSiSe 4

Optimized growth of high length-to-diameter ratio Lu 2 O 3 single crystal fibers by the LHPG method

Investigation on nonlinear optical properties of ZrGeTe4 nanosheets and its application in ultrafast photonic

Crystal Growth, Characterization, and Properties of Nonlinear Optical Crystals of Li x Ag 1- x GaSe 2 for Mid-Infrared Applications

Vertical Bridgman Growth and Characterization of Large ZnGeP2 Single Crystals

Rational Design of a Niobium Tellurite Crystal Nb2Te3O11 Exhibiting Good Overall Infrared NLO Performance by Structural Genetic Engineering

Flux Growth and Optical Properties of the NLO Cd3Zn3B4O12 Crystal

Crystal growth, finite element analysis and oxygen annealing of ZnO bulk crystal grown by low-temperature-gradient chemical vapor transport

Two Acentric Zn-Based l-Tartrates with Moderate Second Harmonic Generation Responses and Large Birefringence

Hexagonal ZnTiO3 monocrystalline films on LiNbO3 substrates: Structural and optical properties

Growth of large size near-stoichiometric lithium niobate single crystals with low coercive field for manufacturing high quality periodically poled lithium niobate

Microstructure, Growth Mechanism and Anisotropic Resistivity of Quasi-One-dimensional ZrTe5 Crystal

α-Li 2 ZnGeS 4 : A Wide-Bandgap Diamond-like Semiconductor with Excellent Balance between Laser-Induced Damage Threshold and Second Harmonic Generation Response

Effect of Li/Nb ratio on structure and photorefractive properties of Zn:Fe:LiNbO<sub>3</sub> crystals