Dissimilar joining of AZ31B and Ti–6Al–4V sheets in lap joint using cold metal transfer welding

Lucky Thakur,S. Aravindan
DOI: https://doi.org/10.1080/01694243.2024.2362927
IF: 2.431
2024-06-09
Journal of Adhesion Science and Technology
Abstract:Ti–6Al–4V and AZ31B alloy sheets were joined in lap joint configuration using cold metal transfer welding with a synergic power source. The torch angle was kept approximately 45° away from the top plate. Wire feed speeds (WFSs) have been varied from 3.0 m/min to 7.0 m/min. Cold metal transfer welding results in good deposition of weld metal at higher WFSs but at the cost of poor bonding and defects. Joints of the best qualities were fabricated at a WFS of 3.0 m/min and a welding speed of 0.6 m/min. The torch angle assisted in the proper deposition of AZ31B weld metal with a good bond between weld metal and Ti–6Al–4V base metal. Microstructural analysis confirms the joint interface integrity by revealing the absence of defects. Also, there is a significant variation among the grain morphology of weld region, transition zone and base metal. The presence of several oxides (MgO 4 , Al 2 O 3 , etc.) and intermetallics (Mg 17 Al 12 , Mg 7 Zn 3 , AlMg 4 Zn 11 , etc.) is indicated by metallurgical analyses. Tensile-shear tests revealed that the joints could sustain the maximum load of 1871 N. Fractography reveals the mixed mode of fracture containing majority brittle, and a ductile failure at a few locations. The unusual fracture at a few locations indicates the presence of oxides in these regions.
materials science, multidisciplinary,engineering, chemical,mechanics
What problem does this paper attempt to address?