Abstract:The co-firing of various ultra-low volatile coal-based solid wastes (CSWs) under oxy-fuel condition is a promising approach to elevate the energy conversion efficiency in coal chemistry industry. However, the kinetics and thermal transformation mechanisms during oxy-fuel co-combustion of various CSWs blends are still vague, which need to be further elucidated. Here, the physical–chemical features of CSWs were firstly revealed. Moreover, the oxy-fuel co-combustion characteristics and kinetics of various CSWs were investigated. The results illustrate that four chemical forms of fuel nitrogen could be obtained in pyrolyzed semi-coke (PS), while only two occurrence forms of fuel nitrogen were observed in two residual carbons, including fluidized bed gasification residual carbon (FRC) and coal-water-slurry gasification residual carbon (CRC). The reactivities of various samples could be promoted by the increasing temperature during gasification process. The combustion of volatile matter and fixed carbon could be promoted by an increase in oxygen content in oxy-fuel atmosphere. The combustion characteristic index (S) of 50% PS/50% CRC is raised by 59.3% and that of 50% PS/50% FRC is increased by only 19.0% with the oxygen concentration elevated from 30 to 40%. The effects of rising residual carbon proportion on PS/CRC blend are more obvious than those on PS/FRC blend. The additive of PS in blend could promote the combustion behaviors of residual carbon, especially on CRC. The mass loss rate of 50% PS/50% CRC blend changes significantly with the heating rate, which is greater than that of 50% PS/50% FRC blend. The average apparent activation energy (Eam) of 50% PS/50% CRC blend is lower than that of linear calculation result. The Eam of CRC could be reduced by blending PS, and the poor combustion behaviors of CRC are improved by addition of PS.Graphic abstract

Kinetic and Synergetic Effect Analysis of the Co-Combustion of Coal Blended with Polyurethane Materials

Experimental study on thermal effect and gas release laws of coal-polyurethane cooperative spontaneous combustion

Investigation of the synergistic effect and kinetic behavior of anthracite and biochar during co-combustion process in pure oxygen atmosphere

Co-combustion of Coal and Carbonaceous Wastes: Thermogravimetric Analysis

Kinetic Study on Co-Combustion of Pulverized Anthracite and Bituminite for Blast Furnace Injection

Experimental study on co-firing characteristics of coal/biomass blends in O2/CO2 atmosphere

Thermodynamics and synergistic effects on the co-combustion of coal and biomass blends

Experimental investigation on co-combustion characteristics of semi-coke and coal: Insight into synergy and blending method

Co-pyrolysis Behavior of Coal and Biomass: Synergistic Effect and Kinetic Analysis

Catalytic and Non-Catalytic Synergistic Effects and Their Individual Contributions to Improved Combustion Performance of Coal/biomass Blends

Effect of different conditions on the combustion interactions of blended coals in O 2 /CO 2 mixtures

Synergistic effect and volatile emission characteristics during co-combustion of biomass and low-rank coal

Pressurized Oxy-Fuel Combustion of Pulverized Coal Blended with Wheat Straw: Thermochemical Characterization and Synergetic Effect

Oxy-fuel co-combustion characteristics and kinetics of various ultra-low volatile coal-based solid waste blends

Co-combustion of pulverized coal and walnut shells in air and oxy-fuel atmospheres: Thermal behavior, synergistic effect and kinetics

The Combustion of Forest Humus Blended with Low-Rank Coal: Effects of Oxygen Ratio and Blending Ratio

Physicochemical characteristics of biomass‐coal blend char: The role of co‐pyrolysis synergy

Co-Combustion Characteristics of Typical Biomass and Coal Blends by Thermogravimetric Analysis

Investigation on co-combustion of semi-coke and bituminous coal in oxygen-enriched atmosphere: Combustion, thermal conversion, and kinetic analyses

Co-combustion Characteristics and CO2 Emissions of Low-Calorific Multi-Fuels by TG-FTIR Analysis

Influence of the synergistic effects between coal and hemicellulose/cellulose/lignin on the co-combustion of coal and lignocellulosic biomass