Abstract:Introduction: Copper-64 (64Cu, t1/2 = 12.7 h) is a positron emitter well suited for theranostic applications with beta-emitting 67Cu for targeted molecular imaging and radionuclide therapy. The present work aims to evaluate the radionuclidic purity and radiochemistry of 64Cu produced via the 68Zn(p,nα)64Cu nuclear reaction. Macrocyclic chelators DOTA, NOTA, TETA, and prostate-specific membrane antigen ligand PSMA I&T were radiolabeled with purified 64Cu and tested for in vitro stability. [64Cu]Cu-PSMA I&T was used to demonstrate in vivo PET imaging using 64Cu synthesized via the 68Zn(p,nα)64Cu production route and its suitability as a theranostic imaging partner alongside 67Cu therapy. Methods: 64Cu was produced on a 24 MeV TR-24 cyclotron at a beam energy of 23.5 MeV and currents up to 70 μA using 200 mg 68Zn encapsulated within an aluminum‑indium-graphite sealed solid target assembly. 64Cu semi-automated purification was performed using a NEPTIS Mosaic-LC synthesis unit employing CU, TBP, and TK201 (TrisKem) resins. Radionuclidic purity was measured by HPGe gamma spectroscopy, while ICP-OES assessed elemental purity. Radiolabeling was performed with NOTA at room temperature and DOTA, TETA, and PSMA I&T at 95 °C. 64Cu incorporation was studied by radio-TLC. 64Cu in vitro stability of [64Cu]Cu-NOTA, [64Cu]Cu-DOTA, [64Cu]Cu-TETA, and [64Cu]Cu-PSMA I&T was assessed at 37 °C from 0 to 72 h in human blood serum. Preclinical PET imaging was performed at 1, 24, and 48 h post-injection with [64Cu]Cu-PSMA I&T in LNCaP tumor-bearing mice and compared with [68Ga]Ga-PSMA I&T. Results: Maximum purified activity of 4.9 GBq [64Cu]CuCl2 was obtained in 5 mL of pH 2-3 solution, with 2.9 GBq 64Cu concentrated in 0.5 mL. HPGe gamma spectroscopy of purified 64Cu detected <0.3 % co-produced 67Cu at EOB with no other radionuclidic impurities. ICP-OES elemental analysis determined <1 ppm Al, Zn, In, Fe, and Cu in the [64Cu]CuCl2 product. NOTA, DOTA, TETA, and PSMA I&T were radiolabeled with 64Cu, resulting in maximum molar activities of 164 ± 6 GBq/μmol, 155 ± 31 GBq/μmol, 266 ± 34 GBq/μmol, and 117 ± 2 GBq/μmol, respectively. PET imaging in PSMA-expressing LNCaP xenografts resulted in high tumor uptake (SUVmean = 1.65 ± 0.1) using [64Cu]Cu-PSMA I&T, while [68Ga]Ga-PSMA I&T yielded an SUVmean of 0.76 ± 0.14 after 60 min post-injection. Conclusions: 64Cu was purified in a small volume amenable for radiolabeling, with yields suitable for preclinical and clinical application. The 64Cu production and purification process and the favourable PET imaging properties confirm the 68Zn(p,nα)64Cu nuclear reaction as a viable 64Cu production route for facilities with access to a higher energy proton cyclotron, compared to using expensive 64Ni target material and the 64Ni(p,n)64Cu nuclear reaction. Advances in knowledge and implications for patient care: Our 64Cu production technique provides an alternative production route with the potential to improve 64Cu availability for preclinical and clinical studies alongside 67Cu therapy.

Excitation functions of proton-induced nuclear reactions on natCaCO3 up to 60 MeV

Proton-induced reactions for 47Sc (and 46Sc) production: new nuclear cross section measurements on enriched titanium targets

Excitation functions for Sc radioisotopes production via (α,x) nuclear reactions on natural calcium up to 25 MeV

Optimized simulations of 50Ti(p,α) and 49Ti(d,α) reactions for hospital-cyclotron production of 47Sc

44Sc production from enriched 47TiO2 targets with a medical cyclotron

Cross section measurements for the production of 49,51Cr and 47Sc from proton irradiation of natural vanadium up to 24 MeV

Improved procedures of Sc(OH)3 precipitation and UTEVA extraction for 44Sc separation

Production of scandium-44m and scandium-44g with deuterons on calcium-44: cross section measurements and production yield calculations

Measurement and Modeling of Proton-Induced Reactions on Arsenic from 35 to 200 MeV

[Nat/44sc(pypa)]-: Thermodynamic Stability, Radiolabeling, and Biodistribution of a Prostate-Specific-Membrane-Antigen-Targeting Conjugate.

Production of Medical Radioisotopes with High Specific Activity in Photonuclear Reactions with $γ$ Beams of High Intensity and Large Brilliance

Production of 45Ti radioisotope by proton irradiation of natural scandium

Statistical analysis of proton induced reactions to generate recommended data for the production of medical radio-isotopes

Theoretical assessment and targeted modeling of TiO2 in reactor towards the scandium radioisotopes estimation

Measurement of the 12 C(p,n) 12 N reaction cross section below 150 MeV

Target Development towards First Production of High-Molar- Activity 44gSc and 47Sc by Mass Separation at CERN-MEDICIS

Separation of 44Sc from Natural Calcium Carbonate Targets for Synthesis of 44Sc-DOTATATE

64Cu production via the 68Zn(p,nα)64Cu nuclear reaction: An untapped, cost-effective and high energy production route

Proton radiographs using position-sensitive silicon detectors and high-resolution scintillators

Cyclotron Production and Separation of Scandium Radionuclides from Natural Titanium Metal and Titanium Dioxide Targets

Generation of neutron spectra and emission yields from proton-induced reactions on nat C and nat Li targets using CR-39 detectors