Abstract:Concentrated solar power (CSP) plants utilize two-tank, sensible-heat thermal energy storage (TES) for uninterrupted electricity generation. However, the cost for the design and operation of TES is expensive. Therefore, researchers are focusing on implementing single-tank storage. Additional cutbacks can be made by utilizing pump-less thermosyphon charging for the TES. But prior thermosyphon researches for TES are related to domestic water-heating systems of small-capacity (<100 liters) and low-temperature (<100 °C). Thus, investigations into thermosyphon charging for high-temperature storage are desired. This study focuses on thermosyphon-charging and storing of a single-medium stratified TES. The experiments were conducted on a 370 liters cylindrical storage (aspect ratio 4:1) with a heat-pipe system (3-liter volume) acting as a collector. Dowtherm-A oil was used as the heat transfer fluid (HTF), and the thermal expansion of HTF was accommodated in an expansion tank via two different designs (top and bottom connections from storage tank to expansion tank). Moreover, continuous and pulsatile charging are investigated for low (150 °C) and high (250 and 300 °C) temperatures. The results indicate that the maximum HTF temperature coming out of the heating pipes is ~25 °C more for the bottom-expansion design. Furthermore, it results in higher charging efficiency than the top-expansion setup for high-temperature studies. Finally, it is revealed that under design conditions, there are limits on the degree of thermal stratification achieved in the charging cycle and the maximum layover time allowable for interrupted charging. These results provide insights into the operational strategy of thermosyphon-charging stratified storage for CSP applications.

Numerical investigation on simultaneous charging and discharging process of molten-salt packed-bed thermocline storage tank employing in CSP plants

Thermal insulation for a high temperature molten salt storage tank in a CSP plant

Investigation on Performance of Multi-Salt Composite Sorbents for Multilevel Sorption Thermal Energy Storage

Influence characteristic and improvement mechanism of thermal storage performance of Packed-bed thermocline tank based on high-temperature molten salt

STUDY ON CHARGING AND DISCHARGING RATES OF LATENT HEAT THERMAL ENERGY STORAGE SYSTEMS EMPLOYING MULTIPLE PHASE CHANGE MATERIALS

Cyclic Operation of Molten-Salt Thermal Energy Storage in Thermoclines for Solar Power Plants

Molten-salt Thermal Energy Storage in Thermoclines under Different Environmental Boundary Conditions

Anisotropic heat characteristics and analysis of molten salt thermocline storage system

Thermal analysis of solar thermal energy storage in a molten-salt thermocline

Assessing the performance of novel molten salt mixtures on CSP applications

Coupled Thermal and Mechanical Dynamic Performances of the Molten Salt Packed-Bed Thermal Energy Storage System

Comparative investigation of charging performance in shell and tube device containing molten salt based phase change materials for thermal energy storage

Performance investigation on the cascaded packed bed thermal energy storage system with encapsulated nano-enhanced phase change materials for high-temperature applications

Review of Molten-Salt Thermocline Tank Modeling for Solar Thermal Energy Storage

Development and numerical investigation of parallel combined sensible-latent heat storage unit with intermittent flow for concentrated solar power plants

Optimization of the packed-bed thermal energy storage with cascaded PCM capsules under the constraint of outlet threshold temperature

Thermal Cycling Test of Solar Salt in Contact with Sustainable Solid Particles for Concentrating Solar Power (CSP) Plants

Experimental investigation on the performance of thermosyphon charging of a single-medium stratified storage system for concentrated solar power applications

An effective thermal conductivity correlation for three high-temperature chloride salts melting in a spherical thermal storage capsule

Synthesis and Characterization of Molten Salt Nanofluids for Thermal Energy Storage Application in Concentrated Solar Power Plants-Mechanistic Understanding of Specific Heat Capacity Enhancement

An Experimental Investigation of Temperature Distribution and Heat Loss in Molten Salt Tanks in Concentrating Solar Power Plants