Study on the transformation of Zn, Mn and Cr during sewage sludge combustion
Hao Liu,Yajun Wang,Xiaohan Ren,Huanhuan Xu,Juan Chen
DOI: https://doi.org/10.1016/j.psep.2022.03.081
IF: 7.8
2022-05-01
Process Safety and Environmental Protection
Abstract:Sewage sludge combustion experiments were carried out to investigate the migration and transformation of Zn, Mn, and Cr involved with the effects of combustion temperature, atmosphere, and steam concentration. The results showed that the volatilization of Zn was promoted by a temperature increase. Compared to air combustion, the inhibited volatilization of ZnCl2(g) and the production of ZnO promoted the recovery of Zn in ash during oxy-fuel combustion. Furthermore, the increasing temperature typically improved aluminosilicate capture MnO as well as the capability of CaO/Fe2O3 on capturing Cr. The reducing atmosphere caused by high CO2 concentration in oxy-fuel combustion facilitated the enrichment of Mn and Cr in ash. Steam favored the retention of Zn via transformation to form stable ZnO·A12O3·2SiO2 condensed into solid ash. The generation of CO and H2 from char-steam/char-CO2 gasification induced a local reducing atmosphere. It accelerated the transformation of MnO2 to MnO and facilitated the combination between MnO and aluminosilicate. Fe(III) reduced to Fe(II) strengthened the ability of iron oxide to capture Cr. The presence of steam promoted the decomposition of Ca-based minerals in the sewage sludge into a porous CaO, which enhanced the effect on Cr retention.Ti-extraction blast furnace slag (TEBFS) is an industrial solid waste, which is harmful to the environment and sustainable development of China's titanium industry. The efficient utilization of TEBFS is therefore urgently needed. In this study, calcium silicate boards were successfully prepared as partition materials. The effects of TEBFS content, cement content, calcium silicon mass (Ca/Si) ratio, and the Cl content of TEBFS on the material properties, pore structure, and phase composition of calcium silicate boards were explored. The results revealed that with an increase in TEBFS content, the average pore diameter of prepared samples gradually decreased. Furthermore, an excessive amount of cement and an excessively high Ca/Si ratio were not conducive to improving material properties. Optimum samples were prepared with 70 wt% TEBFS, 15 wt% Portland cement, and a Ca/Si ratio of 0.9. Under these conditions, the bulk density of the material was 1.64 g/cm3, the water absorption was 21.0%, and the flexural strength was 11.0 MPa. An identically prepared calcium silicate board using dechlorinated TEBFS had a flexural strength of 9.8 MPa, demonstrating the importance of chlorine in the calcium silicate formation process. This study provides an important reference for solving the waste management and recycling problems of TEBFS.Studies of overpressure loads are essential to mitigate the potential hazards of public safety induced by gas explosion accidents. Based on the computational fluid dynamics (CFD) code FLACS, numerical models of gas explosions in large-scale tunnels were developed and verified by comparing with testing data. Numerical simulations of gas explosions in confined and side-vented utility tunnels were carried out. The effects of the venting condition, gas cloud volume, and ignition position were analyzed and discussed. It is found that gas explosions in utility tunnels can be divided into three stages according to the pressure and flame development, i.e., the combustion-induced rise stage, oscillation rise stage, and oscillation decline stage. The pressure oscillation is significant, and a side vent near the tunnel end can reduce the peak pressure by 42~78% and the oscillation peak by 35~87%. The peak pressure, oscillation peak, and duration of oscillation rise stage varied significantly with the gas cloud volume. When the premixed gas cloud is ignited at the 1/4 L, the peak pressure and oscillation peak reach the maximum of 1242.5 kPa and 490.4 kPa for confined cases, which are one time higher than those of side-vented cases. What is more, based on the equivalent single degree of freedom (SDOF) approach in the elastic range, the dynamic effects of gas explosions in utility tunnels are figured out, and suggestions for engineering practice are proposed.Coastal reservoirs could be used to store freshwater in coastal cities, but the conversion of coastal reservoirs to freshwater reservoirs is relatively time-consuming, and coastal reservoirs are facing a risk of salinization. Taking Zhuyu Lake as the research object, the Spatio-temporal variations of water salinity under different seasons were investigated using the field survey and modeling. The influencing factors of the water salinity of the reservoir were analyzed to discover the variation mechanism. The results showed that the disturbance of overlying water is the most significant factor affecting the salt release of sediment -Abstract Truncated-
engineering, environmental, chemical