The Production of Bioethanol from Corncob as Fuel for Generator Set of Gasoline Motor
C. A. Wicaksana,Widiyanti Widiyanti,M. A. Mizar
DOI: https://doi.org/10.2991/ICOVET-17.2017.32
2017-11-01
Abstract:Along with the development of the era and the technology, which are rapidly growing every time, the global communities receive both positive and negative impacts from these advancements. One of the negative effects is the issue of waste. Physically, there are three types of waste: solid, liquid, and gas. In general, organic waste is contributing the most to the amount of waste currently. One of the examples of solid waste, which comes from the agricultural process, is corncob. Corncob is often only used for animal feed or as a substitute for firewood in the absence of further treatment. These simple utilization of corncob, decrease either value of its usability or its economic value. One of the efforts to improve the usability and economic value of corncob is by processing it into bioenergy, such as bioethanol. The purpose of this study is to explore the bioethanol production process from corncob and to find out the level of purity of the ethanol, which is resulted from the same bioethanol production process. This study employed experimental as its design. The results expose that corncob can be used as the raw material for producing bioethanol which underwent several processes; pretreatment, hydrolysis for a day, fermentation for seven days, and four times of distillation process with the temperature of 52 – 72,5C and the pressure of 95,5 – 107,3 mBar, which produce ethanol of 96%. Keywords—alternative energy; bioethanol from corncob; fuel for generator set In this modern era, the problem of waste management has become a significant global issue. This issue is mainly caused by the increasing amount of the waste, but there has not been an effort to degrade the adverse effect of the waste Physically, the waste consists of three types; they are gases, liquids, and solids. The biggest contributor to the waste type produced in urban areas is the organic wastes which approximately reach the amount of 65%. One of the types of organic solid waste which have not been exploited to its full potential is the waste of agricultural output in the form of corncob. Corncob is one of the inner parts of the female organ. Commonly, corncob is utilized as livestock feed. Thus, it possesses low consumption and economic value. The utilization of corncob waste can be carried out with the method of bioconversion, which emphasizes the transformation of the waste into fuel by involving microorganisms in the manufacturing process. During 1969 – 2015, the highest peak of corn production in Indonesia was reached by 2015 with the results of 20.667 million tons . The current primary energy consumption of the community consists of 3.11% of water power, 1.32% of geothermal, 51.66% of petroleum, 15.34% of coal and 28.57% of gas . The estimated numbers of world energy consumption will increase by as much as 57% from 2002 to 2025 [4] which where an increasing number of greatest consumption occurred in the various areas within developing countries, such as Indonesia. Bioethanol is one of the biofuels which never get expired as long as the Sun is shining, the water is available, the need for oxygen is fulfilled, and the existence of agriculture cultivation . Bioethanol has several advantages when compared to conventional fuel oil, i.e. has a higher oxygen content (35%) so that the burning is more perfect, higher octane value (118) and more environmentally friendly because it contains lower levels of CO 19 – 25% . Therefore, bioethanol is the most recommended alternative energy, which is renewable and it can handle the pollution issues. The involved raw International Conference On Vocational Education And Training (ICOVET 2017) Copyright © 2017, the Authors. Published by Atlantis Press. This is an open access article under the CC BY-NC license (http://creativecommons.org/licenses/by-nc/4.0/). Advances in Social Science, Education and Humanities Research, volume 116
Engineering,Environmental Science,Agricultural and Food Sciences