Abstract:Innovations in lithium-ion batteries rely crucially on the availability of advanced characterization techniques. High-resolution chemical imaging of low-Z elements e.g., lithium (Li) is often difficult in many conventional chemical analysis techniques such as Energy-Dispersive X-ray Spectroscopy. High-resolution Secondary Ion Mass Spectrometry (SIMS) imaging is a well-known technique for the analysis of all elements including isotopes. For this reason, SIMS imaging is used in numerous studies related to Li-ion battery research. While direct imaging of Li in post-mortem battery components is helpful to understand parts of the degradation mechanisms, a complete dynamic view of the evolution of the Li distribution at high resolution during operation (‘ operando ’) of batteries is required to fully understand the local interfacial processes, charge transport characteristics and the degradation mechanisms. A few reports presenting operando Time-of-Flight SIMS imaging of batteries have recently been published [1], but the lateral resolution demonstrated in these reports is not adequate to study local processes that occur at nanoscale. In order to demonstrate operando SIMS chemical imaging with sub-20 nm lateral resolution, we developed a novel operando methodology suitable for Focused Ion Beam (FIB)-SIMS imaging and analysis (see Fig. 1). An in-house designed magnetic-sector mass spectrometer [2] attached to a ThermoFisher SCIOS Ga + FIB is used for SIMS chemical imaging. A special operando sample holder was designed to enable electrochemical cycling of batteries within the FIB-SIMS instrument. The micromanipulator inside the FIB (typically used for preparing thin lamellae for Transmission Electron Microscopy) is used to contact one of the battery electrodes through the operando sample holder and complete the electrical circuit. An external potentiostat is then connected to the instrument to drive the charging/discharging of batteries. The proof-of-concept experiments were performed using Li|Li 7 La 3 Zr 2 O 12 |Li symmetric half-cells. Galvanostatic cycling was performed in-situ inside the FIB-SIMS instrument until the sample failed. SIMS chemical mapping revealed a redistribution of Li during cycling. Lithium rich phases appeared during cycling which likely percolated through grain-boundaries and pores of the solid electrolyte causing a short-circuit failure. These results validate our methodology for operando analysis of Li-ion batteries with the possibility to obtain SIMS chemical images with sub-20 nm lateral resolution [3]. This work was funded by the Luxembourg National Research Fund (FNR) through the grant INTER/MERA/20/13992061 (INTERBATT). [1] Y. Yamagishi, et al., J. Phys. Chem. Lett. 2021, 12, 19, 4623–4627 [2] O. De Castro, et al., Analytical Chemistry, 2022, 94, 30, 10754–10763. [3] L. Cressa, et al., Analytical Chemistry, 2023, under review. Figure 1

Lift-Out Specimen Preparation and Multiscale Correlative Investigation of Li-Ion Battery Electrodes Using Focused Ion Beam-Secondary Ion Mass Spectrometry Platforms

High-Spatial-Resolution Quantitative Chemomechanical Mapping of Organic Composite Cathodes for Sulfide-Based Solid-State Batteries

Chemometric and Machine Learning Analysis of Lithium Concentration and Solvation Behavior in Li-Ion Battery Electrolytes

Enhanced Imaging of Lithium Ion Battery Electrode Materials

Towards Operando Secondary Ion Mass Spectrometry Imaging of Lithium Redistribution in Solid-State Lithium-Ion Batteries: Correlation of Structural, Chemical and Electrochemical Characteristics

Multi-Scale Correlative Tomography of a Li-Ion Battery Composite Cathode

Multiscale Characterization of Composite Electrode Microstructures for High Density Lithium-ion Batteries Guided by the Specificities of Their Electronic and Ionic Transport Mechanisms

(Digital Presentation) Chemical Workflow of Characterizing Lithium-Ion Battery Electrodes: From SEM-Eds PCA and FIB Tof-SIMS Analysis to XPS

Nanoscale Imaging of Lithium Ion Distribution During In Situ Operation of Battery Electrode and Electrolyte

Three-dimensional operando optical imaging of particle and electrolyte heterogeneities inside Li-ion batteries

Three-dimensional operando optical imaging of single particle and electrolyte heterogeneities inside Li-ion batteries

Facilitating the systematic nanoscale study of battery materials by atom probe tomography through in-situ metal coating

Morphological Evolution of NMC Secondary Particles Through in situ electrochemical FIB/SEM experiment

Scanning Probe Microscopy Facility for Operando Study of Redox Processes on Lithium ion Battery Electrodes

Atomic-Scale Characterization of Microscale Battery Particles Enabled by a High-Throughput Focused Ion Beam Milling Technique

Nanoscale imaging of fundamental li battery chemistry: solid-electrolyte interphase formation and preferential growth of lithium metal nanoclusters

Direct Multielement Analysis of Polydisperse Microparticles by Classification-Single-Particle ICP-OES in the Field of Lithium-Ion Battery Electrode Materials

Real-time mass spectrometric characterization of the solid–electrolyte interphase of a lithium-ion battery

Operando optical tracking of single-particle ion dynamics in batteries

Hyphenated DEMS and ATR-SEIRAS techniques for <i>in situ</i> multidimensional analysis of lithium-ion batteries and beyond

Coupling liquid electrochemical TEM and mass-spectrometry to investigate electrochemical reactions occurring in a Na-ion battery anode