Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Aerodynamic Drag of a Tilt-Rotor UAV During Forward Flight in Rotary-Wing Mode

Experimental Study to Quantify the Rotor-to-Rotor Interaction Characteristics of a Small Unmanned-Aerial-Vehicle

Aerodynamic performance assessment of a ducted fan UAV for VTOL applications

Aerodynamic Analysis of Rotor Spacing and Attitude Transition in Tilt-Powered Coaxial Rotor UAV

A Study on the Aerodynamic Impact of Rotors on Fixed Wings During the Transition Phase in Compound-Wing UAVs

Aerodynamic Modeling and Verification of Quadrotor UAV Using Wind-Tunnel Test

Aerodynamic Simulation of a Typical Multirotor e VTOL Aircraft Configuration.

Computational fluid dynamics analysis of aerodynamic characteristics in long-endurance unmanned aerial vehicles

Wind Tunnel Testing and Analysis of a Rigid, Variable Speed Rotor for eVTOL Applications

Numerical analysis of wind effects on aerodynamic characteristics of a ducted fan

Design and Control of a VTOL Aerial Vehicle Tilting its Rotors Only with Rotor Thrusts and a Passive Joint

Numerical study on aerodynamic performance of a ducted tail rotor in hover and sideward flight

Unsteady aerodynamics of a micro flapping rotary wing in forward flight

Design and Performance of a Novel Tapered Wing Tiltrotor UAV for Hover and Cruise Missions

An Experimental and Numerical Evaluation of the Aerodynamic Performance of a UAV Propeller Considering Pitch Motion

Numerical Study on Dynamic Performance of a Ducted Fan Moving in Proximity to Ground and Ceiling

Modelling and numerical analysis of attitude control flaps of a UAV

Dynamic Modeling and Control for Tilt-Rotor UAV Based on 3D Flow Field Transient CFD

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

An Experimental Study of Wind Resistance and Power Consumption in MAVs with a Low-Speed Multi-Fan Wind System

Numerical simulation and verification of rotor downwash flow field of plant protection UAV at different rotor speeds